JETSURF RACE TITANIUM - JETSURF OWNERS AGREEMENT

85
|10| TROUBLESHOOTING
IF THE POWER BOARD OWNER DOES NOT HAVE SUFFICIENT EXPERIENCE
OR IS IN ANY DOUBTS REGARDING THEIR ABILITY TO PERFORM THE RE-
PAIR, IT IS NECESSARY TO LEAVE THE REPAIR TO THE QUALIFIED MECHA-
NICS OF JetSurf™ COMPANY WHO HAVE BEEN TRAINED BY THE MANU-
FACTURER AND ARE CERTIFIED FOR IT.
ISSUE Defect, symptoms REPAIR – step 1 REPAIR – step 2
The power board
does not start,
the engine turns
Water in the engine
- symptoms: white emulsion
on the spark plug
Clean the spark plug,
p. 71
Clean the en-
gine, p. 66
Too much fuel in the engine -
- symptoms: the spark plug
is soiled with petrol
Clean the spark plug,
p. 71
Replace the
carburettor
No fuel in the engine
- symptoms: dry spark plug,
empty fuel tubing
Check the fuel
system
Rell the fuel
Faulty spark plug
– symptoms: the spark plug
does not spark
1. Replace the spark
plug, p. 71
If implementing
of 1 and 2 did not
help, try a new
coil and ICU
Faulty timing sensor
– symptoms: the spark plug
sparks after the engine shut-
o key is pulled out
2. Replace the timing
sensor
The power board
does not start,
the engine does
not turn, the ICU
does not ash
Flat battery Charge the batteries,
p. 46
Faulty contact in the cables
of the control handle
Clean the contacts Replace
the control
handle
The relay in the control
handle does not detect the
engine shut-o key
Damaged ICU cable Replace the ICU
Faulty ICU Replace the ICU
The power board
does not start,
the engine does
not turn, the ICU
ashes
Burnt starter winding Replace the starter
Jammed engine or stuck jet
pump
Replace the Engine
or jet pump
Do not remove the boot from the spark plug if there is water or leaked
petrol in the engine compartment. Pay special attention to petrol va-
pours. If you can smell petrol, NEVER start the engine.
When checking the spark plug and timing sensor function, ALWAYS use a
mounting tool supplied in the accessories to check the sparks.
TROUBLESHOOTING
MOTORIZED SURFBOARD MODEL:
Hull Identication Number (HIN):
Serial Number (SN):
Seller:
Board Owner Name:
Address:
City, State/Province, Code:
E-mail:
Signature of Board Owner: Signature of Seller:
Purchase Date: Year: Month: Day:
I have read and understand these terms and conditions and I am aware that taking ANY of the
above steps will void and nullify the JetSurf™ warranty.
I have completed and the training conducted by an Authorized JetSurf™ representative and un-
derstand what steps must be undertaken to ensure the JetSurf™ board(s) are maintained, cared
for, serviced and strored.
RACE TITANIUM RACE
ULTRA SPORT FACTORY GP
version 16-R004/EN