Kohler 14RES

To Next Page

To Previous Page

TP-6735 7/17 105Section 7 Wiring Diagrams

Figure 7-5 Schematic Diagram, ADV-8033 (revised design)

Main Page

Table of Contents3
Safety Precautions and Instructions7
Introduction11
List of Related Materials11
Service Assistance12
Section 1 Specifications13
Introduction13
Controller Specifications13
Engine Service13
Engine Specifications13
Alternator Specifications14
Torque Specifications14
Service View15
Section 2 Scheduled Maintenance17
Service Schedule17
Lubrication System19
Low Oil Pressure Shutdown19
Oil Check19
Engine Oil Recommendation19
Oil Change Procedure19
Oil Cooler, 14RES/RESL20
Oil Cooler, 20RES/RESL21
Spark Plugs21
Air Cleaner Service22
Air Cleaner, 14RES/RESL Models22
Air Cleaner, 20RES/RESL Models23
Cooling System24
Exhaust System24
Stepper Motor Coupling24
Battery25
Battery Charger25
Storage Procedure26
Lubricating System26
Fuel System26
Cylinder Lubrication26
Exterior Preparation26
Battery26
Section 3 Troubleshooting27
Introduction27
Initial Checks27
Controller Service Access27
Oncue Troubleshooting27
Troubleshooting Chart27
Controller Troubleshooting36
Section 4 Controller37
Introduction37
RDC and DC Generator Set/Transfer Switch Controllers37
Controller Power37
Connecting the Battery/Fuse F337
Controls and Indicators38
LED Display39
Controller Keypad39
LED Indicators40
Generator Set Operation41
Local Starting and Stopping41
Engine Start Crank Cycle41
Engine Cooldown41
Automatic Operation with Model RRT Transfer Switch41
Automatic Operation with Model RDT or RSB Transfer Switches41
Exercise42
Unloaded Variable-Speed Exercise with Complete System Diagnostics42
Loaded Exercise (with RRT Only)43
Power Failure During Exercise Cycle43
Exerciser Reset43
Exercise Disable43
Test44
Unloaded Test44
Loaded Test (with RRT Only)44
Power Failure During Test Cycle44
Faults45
Warnings45
Shutdowns45
ATS Communication Errors45
Fault Code Noec45
Resetting the Controller after a Fault Shutdown46
Event History46
Model RRT Transfer Switch Operation50
Source Availability50
ATS Control Sequence of Operation50
Time Delays50
Engine and Transfer Time Delays51
Load Control Time Delay51
Model RRT ATS Connection51
Controller Configuration and Adjustment52
Controller Configuration52
Controller Time out52
Controller Firmware Version Number52
Voltage and Frequency Adjustments52
Sitetech Software53
Calibration53
Calibrate Function53
Calibration Factor54
Controller Circuit Board55
Relays and Leds55
Controller Fuse F255
Controller Replacement56
Section 5 Component Testing and Adjustment59
Theory of Operation59
Separate Excitation59
Stator61
Main Field (Rotor)63
Rotor Continuity and Resistance Tests63
Slip Rings64
Brushes64
Voltage Connections66
Voltage Connections, Single-Phase Models66
Voltage Regulation66

Table of Contents

Other manuals for Kohler 14RES

Related product manuals