Kohler 60KRP - Page 4

Table of Contents, continued
TP-6376 3/08Table of Contents4
Section 3 Electrical Connections and Requirements 31.........................................
3.1 Introduction 31..........................................................
3.2 Voltage Selection and Load Connection Procedure 31........................
3.3 Frequency Conversion 35.................................................
3.4 Electrical Power Panel 36.................................................
3.4.1 Battery Charger Power Inlet 36....................................
3.4.2 Block Heater Power Inlet 36.......................................
3.4.3 Circuit Breaker(s), Main 36........................................
3.4.4 Circuit Breakers, GFCI Receptacles 36.............................
3.4.5 Load Lug Assembly 36...........................................
3.4.6 Camlocks, 60--200KRP 36........................................
3.4.7 Duplex GFCI Receptacles 36......................................
3.4.8 Voltage Indicator Lamps 36........................................
3.4.9 Remote Start 2-Terminal Connector 37..............................
3.4.10 Voltage Selector Switch (Located on Generator Set) 37...............
Section 4 Prestart and Operation 39...........................................................
4.1 Introduction 39..........................................................
4.2 Prestart Checklist 39.....................................................
4.3 Weather and Climate Provisions and Operation Limitations 40.................
4.4 Operation 40............................................................
4.4.1 KPC 1000 Controller 41...........................................
4.4.2 Emergency Stop (E-Stop) Switch 41................................
4.4.3 Battery Power Disconnect Switch 41................................
4.4.4 Engine Idle Switch 42.............................................
4.4.5 Fuel Tank Leak Alarm, 400KRP 42.................................
4.4.6 Work Lights 42..................................................
Section 5 General Maintenance 43............................................................
5.1 Introduction 43..........................................................
5.2 Generator Set and Engine 43..............................................
5.3 Trailer 43...............................................................
5.4 Service Schedule 44.....................................................
5.5 Engine Oil Makeup System 46.............................................
5.6 Fuel/Water Separator Bypass Kit 46........................................
5.7 Fuel/Water Separator 47..................................................
5.8 Brake Service 48........................................................
5.9 Axle/Hub Bearing Service 48..............................................
5.10 Suspension Service 48...................................................
5.11 Wheel and Tire Service 48................................................
5.11.1 Wheel Installation Procedure 49...................................
5.11.2 Tires 49.........................................................
5.12 Extended Period Storage 49...............................................
5.12.1 Storage Procedure 49............................................
5.12.2 After Storage Inspection Procedure 49..............................
Section 6 Troubleshooting and Wiring Diagrams 51............................................
6.1 Introduction 51..........................................................
6.2 Generator Set 51........................................................
6.3 Engine 51...............................................................
6.4 Trailer 51...............................................................
6.5 Electrical Power Panel 51.................................................
6.6 Wiring Diagrams 53......................................................
Appendix A Abbreviations 89................................................................