Home
Kohler
Portable Generator
60KRP
Page 92
Kohler 60KRP - Page 92
92 pages
Manual
Save Page as PDF
To Previous Page
To Previous Page
Loading...
E
2006,
2008
by
Kohler
Co.
All
rights
reserved.
TP-6376
3/08a
KOHLER
CO.
Kohler
,
Wisconsin
53044
Phone
920-459-1634,
Fax
920-459-1846
For
the
nearest
sales
and
service
outlet
in
the
US
and
Canada,
phone
1-888-769-3794
KohlerRental.com
91
Table of Contents
Main Page
Product Identification Information
2
Table of Contents
3
Safety Precautions and Instructions
5
Accidental Starting
5
Exhaust System
6
Fuel System
6
Hot Parts
7
List of Related Materials
9
Introduction
9
Service Assistance
10
Section 1 Specifications and Features
11
Introduction
11
Illustrations and Major Components
11
Trailer Specifications
12
Generator Set Specifications
14
General
14
Engine
14
Alternator
14
Controller
14
Electrical Power Panel
17
Generator Set Accessories
21
Battery(Ies)
21
Battery Charger
21
Battery Power Disconnect Switch
21
Engine Block Heater
21
Fire Extinguisher
21
Air Cleaner Restriction Gauge
22
Spare Tire, 60--200KRP
22
Utility Box
22
Voltage Selector Switch
22
Work Lights
22
Fuel Tank and Fuel System
23
Section 2 Trailer Hookup, Transport, and Setup
25
Introduction
25
Trailer Hookup
25
Trailer Tongue Jack
25
Rear Stabilizing Jacks, 400KRP
25
Trailer Hitch
25
Safety Chains/Hooks
25
Electrical Connection, Trailer Lights (Electric Brake System)
25
Trailer Brakes, Electric
25
Pretransport Checklist
26
Over the Road Gross Weight, Height, and Fuel Concerns
26
Roadside Emergency Stopping
27
Tire Changing Procedure
27
Selecting Trailer Location
27
Surface Stability
27
Adequate Air Flow/Heat Dissipation
28
Combustible Materials
28
Exhaust Gases
28
Noise Avoidance and Restrictions
28
Detaching Trailer from Tow Vehicle
28
Electrical Connection, Trailer Lights
28
Trailer Hitch
28
Trailer Tongue Jack
29
Rear Stabilizing Jacks (if Equipped)
29
Safety Chains/Hooks
29
Hoisting Towable Generator Set
29
Single-Point Lifting, 60--200KRP
29
Four-Point Lift Rings, 400KRP
29
Generator Set Removal from Trailer, 60--200KRP
30
Generator Set Removal from Trailer, 400KRP
30
Section 3 Electrical Connections and Requirements
31
Introduction
31
Voltage Selection and Load Connection Procedure
31
Frequency Conversion
35
Electrical Power Panel
36
Battery Charger Power Inlet
36
Block Heater Power Inlet
36
Circuit Breaker(S), Main
36
Circuit Breakers, GFCI Receptacles
36
Load Lug Assembly
36
Camlocks, 60--200KRP
36
Duplex GFCI Receptacles
36
Voltage Indicator Lamps
36
Remote Start 2-Terminal Connector
37
Voltage Selector Switch (Located on Generator Set)
37
Section 4 Prestart and Operation
39
Introduction
39
Prestart Checklist
39
Weather and Climate Provisions and Operation Limitations
40
Operation
40
KPC 1000 Controller
41
Emergency Stop (E-Stop) Switch
41
Battery Power Disconnect Switch
41
Engine Idle Switch
42
Fuel Tank Leak Alarm, 400KRP
42
Work Lights
42
Section 5 General Maintenance
43
Introduction
43
Generator Set and Engine
43
Trailer
43
Service Schedule
44
Engine Oil Makeup System
46
Fuel/Water Separator Bypass Kit
46
Fuel/Water Separator
47
Brake Service
48
Axle/Hub Bearing Service
48
Suspension Service
48
Wheel and Tire Service
48
Wheel Installation Procedure
49
Tires
49
Extended Period Storage
49
Storage Procedure
49
After Storage Inspection Procedure
49
Section 6 Troubleshooting and Wiring Diagrams
51
Introduction
51
Generator Set
51
Engine
51
Trailer
51
Electrical Power Panel
51
Wiring Diagrams
53
Appendix A Abbreviations
89
Related product manuals
Kohler 60RCLA
72 pages
Kohler 60RCLB
84 pages
Kohler Decision-Maker 6000
224 pages
Kohler 6EF
72 pages
Kohler 6VSG
72 pages
Kohler 6.5EFOZ
80 pages
Kohler 65EOZDJ
16 pages
Kohler PRO 6.4E
52 pages
Kohler 6.5-27EFOZD
60 pages
Kohler 6EFKD-Low CO
52 pages
Kohler 20EKOZD
360 pages
Kohler 18EFKOZD
168 pages
To Previous Page
