4
22
INFORMATION ABOUT MAINTENANCE
EN
CLEANING AND CHECKING
OPERATION DESCRIPTION
PERIOD (HOURS)
PAR.
10 250 500 1000 1500 5000
Engine oil level 4.3
Coolant level /
Check of the radiator heat-exchanger surface
(2)
4.8
4.6
External cartridge dry-type air lter
(2)
4.5
Radiator heat-exchange surface and Intercooler
(2)
4.6
Alternator belt tension
(5)
4.9
Rubber hose (intake air / coolant) 4.7
Fuel hose --
Tab. 4.1
4.2 Periodic maintenance
The intervals of preventive maintenance in Tab. 4.1 and Tab. 4.2 refer to the engine operating under normal operating conditions
with fuel and oil meeting the recommended specications.
• This chapter shows all operations described in the Tab. 4.1
and Tab. 4.2 if you have the skills appropriate may be directly
carried out by the user.
• Periodic inspection and maintenance operations must
be carried out as indicated in this manual and are the
responsability of the user.
• Failure to comply with these service and maintenance
intervals increases the risk of technical damage to the engine.
Any non compliance makes the warranty become null and
void.
• In order to prevent personal and property damage read
carefully the instructions listed below before proceeding with
any operation of the engine.
4.1 Useful information about maintenance
Warning
• Inspections must be made when the engine is off and cold.
• Place engine on level surface to ensure accurate
measurement of oil level.
• Before starting, to avoid spillages of oil make sure that:
- the oil dipstick is inserted correctly;
- also check that:
oil drain plug and
oil ller cap are tightened rmly.
(1) - In case of low use: 12 months.
(2) - The period of time that must elapse before checking the
filter element depends on the environment in which the
engine operates.
The air filter must be cleaned and replaced more
frequently under very dusty conditions.
(3) - In case of low use: 36 months.
(4) - In case of low use: 24 months.
(5) - Not Poly-V type.
(6) - The replacement must be carried out by authorized
KOHLER workshops.
Tab. 4.2
REPLACEMENT
OPERATION DESCRIPTION
PERIOD (HOURS)
PAR.
10 250 500 1000 1500 5000
Engine oil
(1)
5.1
Oil lter cartridge
(1)
5.2
5.3
Fuel lter cartridge
(1)
5.4
Alternator Poly-V belt
Alternator V belt
(3) (6)
--
Not heavy environmental condition
(6)
--
Heavy environmental condition
(6)
Coolant
(6)
--
Intake manifold hose (air lter - intake manifold)
(6)
--
Coolant hoses
(6)
--
Dry air cleaner external cartridge
(2) (6)
After 6 checks with cleaning
The replacement must be carried out by
authorized KOHLER workshops
5.5
Fuel line hose
The replacement must be carried out by authorized
KOHLER workshops
UM KDI 1903TCR_2504TCR _ cod. ED0053029490 - 2° ed_rev. 01
To Next Page
Loading...
Need help?
General