Kohler KDI-1903TCR User Manual

6
34
INFORMATION ABOUT FAILURES
EN
6.1 Useful information about failures
•
Thischaptercontainsinformationabouttheproblemsthatmayappearduringengineoperationwithitscausesandtrouble
shootingTab. 6.2.
•
Insomecases,youshallturnofftheengineimmediatelytoavoidfurtherdamage Tab. 6.1.
THE ENGINE MUST BE IMMEDIATELY TURNED OFF WHEN
1
WarningREDlightturnon
2 Theoilpressureindicatorlightturnsonwhilerunning
3 Theenginerpmssuddenlyincreaseanddecrease
4 Asuddenand/orunusualnoiseisheard
5 Colourtheexhaustfumessuddenlydarkens
- IntheeventthatthesolutionsproposedinTab. 6.2donoteliminatethetrouble,contacta KOHLERauthorizedworkshop.
TROUBLES POSSIBLE CAUSE SOLUTION PAR.
Warning YELLOW
light turn on
EngineECUhasdetectamalfunctions ContactKOHLER authorisedworkshops --
The engine does not
start
Sulphatedbatteryterminalscorroded Cleanthebatteryterminals --
Batteryvoltagetoolow Rechargethebatteryorreplaceit --
Lowfuellevel Refuel 3.4
Frozenfuel ContactKOHLER authorisedworkshops --
Cloggedfuellter Replacewithanewlter 5.4
Airsuctioninfuelsystem ContactKOHLER authorisedworkshops --
Cloggedairlter Replacewithanewlter 5.5
Cloggedpipes ContactKOHLER authorisedworkshops --
Openfuse
Replacewithanewfuse;iftheproblempersists,
contactKOHLER authorisedworkshops
--
Intakeorexhaustsystemclogged ContactKOHLER authorisedworkshops --
Enginestartsbutstops
Inefcientelectricalconnections
Cleantheelectricalcontacts;iftheproblempersists,
contactKOHLER authorisedworkshops
--
Sulphatedbatteryterminals Cleanthebatteryterminals --
Cloggedfuellter Replacewithanewlterandcleanthetank --
Cloggedfuelpipes ContactKOHLER authorisedworkshops --
RPM instability at idle
speed
Cloggedfuelpipes ContactKOHLER authorisedworkshops --
Low
idlespeed
Cloggedfuelpipes ContactKOHLER authorisedworkshops --
Poorqualityfuel Cleanthetankandrefuelwithqualityfuel 1.5
Bluesmoke
Highoilsumplevel
Replacetheengineoil;iftheproblempersists,
contactKOHLER authorisedworkshops
--
Cloggedairlter Replacewithanewlter 5.5
Excessivefuel
consumption
Cloggedairlter Replacewithanewlter 5.5
Highoilsumplevel
Replacetheengineoil;iftheproblempersists,
contactKOHLER authorisedworkshops
--
Enginelostitsinitial
performance
Cloggedairlter Replacewithanewlter 5.4
Cloggedfuelpipes ContactKOHLER authorisedworkshops --
Cheapfuel Cleanthetankandrefuelwithqualityfuel --
Highoilsumplevel
Replacetheengineoil;iftheproblempersists,
contactKOHLER authorisedworkshops
--
Slowacceleration
Cloggedfuellter Replacethefuellter 5.4
Enginejerking
Cloggedfuelpipes ContactKOHLER authorisedworkshops --
Engineoverheats
Insufcientcoolantlevel Filluptothelevel 3.6
Highoilsumplevel
Replacetheengineoil;iftheproblempersists,
contactKOHLER authorisedworkshops
--
Cloggedradiator
Cleantheradiator;iftheproblempersists,contact
KOHLER authorisedworkshops
--
Tab. 6.1
Tab. 6.2
UM KDI 1903TCR_2504TCR _ cod. ED0053029490 - 2° ed_rev. 01
Index

Kohler KDI-1903TCR Specifications

General

Brand	Kohler
Model	KDI-1903TCR
Category	Engine
Language	English