Kubota V3300-E2B - Check Points of Every 500 Hours

G-12
V3300-E2B, V3300-T-E2B, WSM
G GENERAL
Checking Battery Electrolyte Level
1. Check the battery electrolyte level.
2. If the level is below than lower level line (2), and the distilled water
to pour level of each cell.
W1047154
Checking Intake Air Line
1. Check to see if the intake air hose(s) are properly fixed every 250
hours of operation.
2. If the clamp is loose, apply oil to the threads and retighten it
securely.
3. The intake air hose(s) is made of rubber and tends to age. It must
be change every two years. Also change the clamp and tighten
it securely.
IMPORTANT■
• To prevent serious damage to the engine, keep out any dust
inside the intake air line.
W1029631
[5] CHECK POINTS OF EVERY 500 HOURS
Replacing Oil Filter Cartridge
CAUTION
• Be sure to stop the engine before changing filter cartridge.
1. Remove the oil filter cartridge (1) with the filter wrench.
2. Apply a slight coat of oil onto the new cartridge gasket.
3. To install the new cartridge, screw it in by hand. Over tightening
may cause deformation of rubber gasket.
4. After the new cartridge has been replaced, the engine oil
normally decrease a little. Thus see that the engine oil does not
leak through the seal and be sure to read the oil level on the
dipstick. Then, replenish the engine oil up to the specified level.
IMPORTANT
■
• To prevent serious damage to the engine, replacement
element must be highly efficient. Use only a KUBOTA
genuine filter or its equivalent.
W1015117
Replacing Fuel Filter Cartridge (Cartridge Type)
Water and dust in fuel are collected in the filter cartridge. So,
change the filter cartridge every 500 hours service.
1. Remove the used filter cartridge with filter wrench.
2. Apply a thin film of fuel to the surface of new filter cartridge gasket
before screwing on.
3. Then tighten enough by hand.
4. Loosen the air vent plug to let the air out.
5. Start engine and check for fuel leakage.
W1037062
(1) Upper Level Line (2) Lower Level Line
(1) Intake Air Hose (2) Clamp
(1) Engine Oil Filter Cartridge
(1) Fuel Filter Cartridge
KiSC issued 06, 2006 A