S-1
V3300-E2B, V3300-T-E2B, WSM
DIESEL ENGINE
1. TROUBLESHOOTING
W1014322
Symptom Probable Cause Solution
Reference
Page
Engine Does Not
Start
No fuel Replenish fuel G-9
Air in the fuel system Vent air G-9
Water in the fuel system Change fuel and
repair or replace fuel
system
–
Fuel hose clogged Clean or replace G-9, 26
Fuel filter clogged Replace G-11, 12
Excessively high viscosity of fuel or engine oil at
low temperature
Use specified fuel or
engine oil
4, G-11
Fuel with low cetane number Use specified fuel 4
Fuel leak due to loose injection pipe retaining nut Tighten retaining nut S-30
Incorrect injection timing Adjust S-20
Fuel camshaft worn Replace S-40
Injection nozzle clogged Clean or replace S-22, 23,
30
Injection pump malfunctioning Repair or replace S-21, 42
Seizure of crankshaft, camshaft, piston, cylinder
or bearing
Repair or replace –
Compression leak from cylinder Replace head
gasket, tighten
cylinder head screw,
glow plug and nozzle
holder
S-30, 31,
32, 33
Improper valve timing Correct or replace
timing gear
S-46
Piston ring and cylinder worn Replace S-49, 50,
67, 72
Excessive valve clearance Adjust S-16
Stop solenoid malfunctioning Replace S-27
Starter Does Not Run Battery discharged Charge G-16, 17
Starter malfunctioning Repair or replace S-25, 54,
73
Key switch malfunctioning Replace –
Wiring disconnected Connect –
To Next Page
Loading...
