Linhai M565Li - Page 71

M565Li OWNER’S/OPERATOR’S MANUAL
16. MAINTENCE
71

More often under severe use, such as dirty or wet conditions to purge water
or dirt contamination from grease fittings and other critical components.
Item Hours When Remarks
Item Hours When Remarks
Brake System Pre-ride Pre-ride Pre-ride inspection item
Auxiliary Brake Pre-ride Pre-ride Pre-ride inspection item
Tires Pre-ride Pre-ride Inspect daily, pre-ride
inspection item
Wheels Pre-ride Pre-ride Pre-ride inspection item
Frame nuts, bolts
fasteners
Pre-ride Pre-ride Pre-ride inspection item


Air Filter Cleaner Daily Daily Inspect-Clean, Replace if necessary
Coolant/Level
Inspection
Daily Daily Replace engine coolant every year


Air Box Sediment
Tube
Daily Daily Drain deposits whenever visible
Headlamp Inspection
Daily Daily Check operation daily; apply
dielectric grease to connector
when replaced
Tail lamp inspection Daily Daily Check operation daily; apply
dielectric grease to socket when
replaced
Battery 100 hrs Monthly Check/clean terminals;
check fluid level
D
Brake pad wear 10 hrs Monthly Inspect periodically

Rear Gear case Oil 100 hrs Monthly Check monthly and change annually

Front Gear case Oil 100 hrs Monthly Check monthly and change annually
Engine Cylinder
Head and Cylinder
Base Fasteners
25 hrs
3
months Inspect (re-torque
required at first service
only)

General Lubrication 50 hrs
3
months Lubricate all fittings, pivots, cables, etc.