LS tractor MT335 - Page 129

To Next Page

To Previous Page

3 -53

HST

1. Hydraulic filter

2. Steering pump

3. Steering unit

4. Steering cylinder

5. HST filter

6. Oil cooler

7. HST unit

8. Hydraulic lift pump

9. Independent PTO valve

10. Front loader valve /

Front outlet valve (optional)

11. Remote control valve

12. Hydraulic lift control valve

13. Down speed control valve

14. Hydraulic lift cylinder

15. Safety valve

Main Page

Table of Contents9
General Notices for Safety15
Note to the Owner - General Information15
Before Using the Tractor17
Manual Scope and Required Training Level19
Metric and Imperial Units Abbreviations21
Product Identification Number (PIN)23
Operator's Manual Storage25
Tractor Orientation26
Safety Precautions (Read this for Safety before Using)27
Notices before Using the Tractor27
Notices When Starting Engine31
Notices While Operating/Using the Tractor32
Notices When Connecting Implement34
Notices When Towing the Tractor35
Notices When Transporting the Tractor35
Notices When Servicing the Tractor after Work36
Notices When Handling Diesel Fuel37
Notices When Leaving the Tractor38
Notices Relating to Toxic Substances38
Tractor Stability39
Ecology and the Environment42
Symbols44
Safety Decals45
Instructional Decals54
Long-Term Storage59
Preparation for Storage59
Check & Maintenance During Storage60
Preparation for Reuse61
Instruction for Safe Operation63
The Name of each Part63
Boarding and Exiting the Tractor65
Boarding the Tractor65
Driver's Seat (HST Type)66
Seat Adjustment67
Seat Belt69
Tilting Steering Wheel70
Ventilation (Cabin Only)70
Exiting the Tractor71
Safety Device72
Hood (Bonnet)72
Fender72
PTO Safety Cover and Protection Cap72
Roll-Over Protective Structure (ROPS)73
Instruments and Controls77
Instrument Panel and Front Controls77
Instrument Panel79
Key Switch86
Turn Signal Light Switch87
Light Switch88
Hazard Warning Light Switch89
Horn Switch90
Grille Work Light Switch90
DPF Switch91
PTO Switch96
PTO Mode Switch96
Shuttle Lever (Mechanical Synchro-Shuttle)97
Throttle Lever97
Throttle Pedal (Mechanical)98
Clutch Pedal (Mechanical)98
Brake Pedals99
Cruise Control Switch (HST Models Only)100
HST Forward/Reverse Pedal (HST Models Only)100
HST Linked Pedal Switch (HST Models Only, Optional)101
ESC Main Switch (Roll-Bar, HST Models Only)102
ESC Speed Up/Down Switch (Roll-Bar, HST Models Only)102
Right-Hand Controls and Cabin Pillar (Cabin Type)103
Main Gear Shift Lever (Mechanical)103
Parking Brake Lever105
Differential Lock Pedal105
Work Light Switch106
Window Wiper&Washer Switch106
Electrical Power Outlet Socket107
Indoor Light107
Audio Player (if Fitted)107
ESC Main Switch108
ESC Speed Up/Down Switch108
Beacon Lamp Switch109
Left-Hand Controls (Cabin Type)110
Range Gear Shift Lever111
PTO Gear Lever (if Fitted)111
Four Wheel Drive Lever (4WD)112
Middle PTO Lever (if Fitted)112
Left / Right-Hand Controls (Roll-Bar Type)113
Main Gear Shift Lever113
Parking Brake Lever114
Differential Lock Pedal115
Work Light Switch115
ESC Main Switch (MEC Models Only)116
ESC Speed Up/Down Switch (MEC Models Only)116
Range Gear Shift Lever117
PTO Gear Lever (if Fitted)117
Four Wheel Drive Lever (4WD)118
Middle PTO Lever (if Fitted)118
Hydraulic System119
Safety Precautions119
Steering System120
Hydraulic Lift Control (MHL) (Cabin Type)120
Hydraulic Lift Control (MHL) (Roll-Bar Type)122
Remote Control Lever and Quick Coupler (Optional)125
Joystick Lever (if Fitted)127
Hydraulic System Diagram128
Operation and Work131
How to Handle New Tractor131
Check Points131
Notices in Handling New Tractor (Engine Brake-In Procedure)131
Engine Start and Stop132
Engine Start132
Start in Cold Weather134
Engine Stop135
How to Drive and Stop136
Transmission Warm-Up in Cold Weather136
How to Drive137
Changing Speed139
Emergency Stop140
Stopping Tractor141
Parking142
Handling Turbocharger (if Fitted)142
Transport on Public Roads143
Safety Rules When Driving Tractor on the Roads143
Light Operation144
7-Pole Connector (Optional)146
Notices When Towing the Tractor147
Notices When Transporting the Tractor149
Field Operations150
Rear 3-Point Linkage150
Power Take-Off (PTO) Operation154
Hitch and Drawbar (Optional)157
Technically Maximum Permissible Mass158
Tires and Load Capacity159
Adjusting Wheel Tracks and Tire Replacement160
Using Front-End Loader (Optional)162
Adjusting Steering Angle165
Recommended Maximum Specification of Implements166
Ballasting Weights (Optional)167
Working in Hazardous Area170
Driving Speed171
Lubrication and Maintenance173
General Information173
Tightening Torque for Normal Assembly174
Standard Torque Data for Hydraulics176
General Specification - Diesel Fuel179
Biodiesel Fuel180
Refueling the Tractor182
Change Engine Coolant to Organic Acid Technology (OAT) Coolant183
Access for Maintenance184
Maintenance Chart185
Lubricants and Capacity189
First 50 Hour Check190
When the Warning Indicator Lights191
Drain Water from Fuel Filter191
Engine Oil Pressure Indicator192
Battery Charging Indicator192
Check before Starting (Daily Check)193
Engine Oil193
Fuel Tank194
Instrument Panel & Indicators194
Turn Signal Lights, Lights and Horn195
Engine Coolant196
Air Cleaner (Dry Type)196
Cleaning of Radiator and Radiator Screen197
Tire Air Pressure and Damage197
Tightening State of Bolts and Nuts of each Part198
Adjustment of Clutch Pedal Play (Mechanical Type)199
Adjustment of Brake Pedal Play200
Adjusting HST Control Linkage (HST Type)201
Every 50 Hour Check202
Lubricating Grease Nipple202
Cleaning of Radiator and Radiator Screen202
Checking Transmission Oil203
Checking Front Axle Oil (4WD)203
Battery Check203
Air Cleaner (Dry Type)203
Hydraulic Hoses and Leakage204
Cleaning Cabin Air Filters204
Every 100 Hour Check205
Checking and Adding Engine Oil205
Every 300 Hour Check206
Replacing Engine Oil and Filter206
Replacing Hydraulic Oil Filter207
Tension Adjustment of Engine Belt208
Toe-In208
Cleaning Fuel Tank209
Every 500 Hour Check210
Changing Front Axle Oil210
Changing Transmission Oil210
Replacing Fuel Filter Element211
Replacing Air Cleaner Element (Dry Type)212
Replacing Cabin Air Filters212
Every 1000Hr or 1-Year Check213
Adjusting Engine Valve Clearance213
Checking Nozzle Injection Pressure213
Every 1500Hr or 2-Year Check214
Replacement of Engine Coolant214
Cleaning Emission Related Parts217
Every 3000Hr Check218
Cleaning Emission Related Parts218
General Maintenance (When Required)219
Air-Bleeding from Fuel System219
Fuse & Main Fuse221
Battery Handling and Notices223
Alternator and Drive Belt - Check227
Tail/Brake Light Bulb and Turn Signal Light Bulb- Replace228
Headlight Bulb - Replace230
Touch-Up Paint Color231
Troubleshooting232
Air Conditioning System (Cabin Type)239
The Name of each Part of Cooling and Heating System239
How to Use Air Conditioner and Heater240
How to Operate Air Conditioner and Heater240
Air Direction Control240
Every 6 Month Check241
Checking Refrigerant Amount241
Cleaning Condenser and Radiator Screen241
Checking Leakage241
Belt Tension Adjustment242
Cleaning and Replacing Cabin Air Filters242
Every Year Check243
Compressor Check243
Control Switch Check243
Troubleshooting244
System Diagram246

LS tractor MT335 - Page 129

Table of Contents

Related product manuals