LS tractor MT345E

To Next Page

To Previous Page

4 -31

③ Attaching points for Front-end loader

 When attaching the front-end loader, refer to the drawings as below.

(Unit : mm)

Main Page

Table of Contents9
General Notices for Safety15
Note to the Owner - General Information15
Before Using the Tractor17
Manual Scope and Required Training Level19
Metric and Imperial Units Abbreviations21
Product Identification Number (PIN)23
Operator's Manual Storage25
Tractor Orientation26
Safety Precautions (Read this for Safety before Using)27
Notices before Using the Tractor27
Notices When Starting Engine31
Notices While Operating/Using the Tractor32
Notices When Connecting Implement34
Notices When Towing the Tractor35
Notices When Transporting the Tractor35
Notices When Servicing the Tractor after Work36
Notices When Handling Diesel Fuel37
Notices When Leaving the Tractor38
Notices Relating to Toxic Substances38
Tractor Stability39
Ecology and the Environment42
Symbols44
Safety Decals45
Instructional Decals52
Long-Term Storage56
Preparation for Storage56
Check & Maintenance During Storage57
Preparation for Reuse58
Instruction for Safe Operation59
The Name of each Part59
Boarding and Exiting the Tractor60
Boarding the Tractor60
Driver's Seat (HST Type)61
Seat Adjustment62
Seat Belt63
Exiting the Tractor63
Safety Device64
Hood (Bonnet)64
Fender64
PTO Safety Cover and Protection Cap64
Roll-Over Protective Structure (ROPS)65
Instruments and Controls67
Instrument Panel and Front Controls67
Instrument Panel69
Key Switch75
Turn Signal Light Switch76
Light Switch77
Hazard Warning Light Switch78
Horn Switch79
Grille Work Light Switch79
DPF Switch80
PTO Switch85
PTO Mode Switch85
Shuttle Lever (Mechanical)86
Throttle Lever86
Throttle Pedal (Mechanical)87
Clutch Pedal (Mechanical)87
Brake Pedals88
Cruise Control Switch (HST Type)89
HST Forward/Reverse Pedal (HST Type)89
Parking Brake Lever90
Left / Right-Hand Controls91
Main Gear Shift Lever (Mechanical)91
Range Gear Shift Lever92
Differential Lock Pedal93
Work Light Switch94
Four Wheel Drive Lever (4WD)94
Hydraulic System95
Safety Precautions95
Steering System96
Hydraulic Lift Control (MHL)97
Remote Control Levers and Quick Couplers (Optional)99
Joystick Lever (if Fitted)100
Hydraulic System Diagram101
Operation and Work103
How to Handle New Tractor103
Check Points103
Notices in Handling New Tractor (Engine Brake-In Procedure)103
Engine Start and Stop104
Engine Start104
Start in Cold Weather106
Engine Stop107
How to Drive and Stop108
Transmission Warm-Up in Cold Weather108
How to Drive109
Changing Speed111
Emergency Stop112
Stopping Tractor113
Parking114
Handling the Turbocharger (if Fitted)114
Transport on Public Roads115
Safety Rules When Driving Tractor on the Roads115
Light Operation116
7-Pole Connector (Optional)117
Notices When Towing the Tractor118
Notices When Transporting the Tractor120
Field Operations121
Rear 3-Point Linkage121
Power Take-Off (PTO) Operation125
Hitch and Drawbar (Optional)127
Technically Maximum Permissible Mass128
Tires and Load Capacity129
Adjusting Wheel Tracks and Tire Replacement130
Using Front-End Loader (if Fitted)131
Adjusting Steering Angle134
Recommended Maximum Specification of Implements135
Ballasting Weights (Optional)136
Driving Speed139
Lubrication and Maintenance141
General Information141
Tightening Torque for Normal Assembly142
Standard Torque Data for Hydraulics144
General Specification - Diesel Fuel147
Biodiesel Fuel148
Refueling the Tractor150
Change Engine Coolant to Organic Acid Technology (OAT) Coolant151
Access for Maintenance152
Maintenance Chart154
Lubricants and Capacity158
First 50 Hour Check159
When the Warning Indicator Lights160
Drain Water from Fuel Filter160
Engine Oil Pressure Indicator161
Battery Charging Indicator161
Check before Starting (Daily Check)162
Engine Oil162
Fuel Tank163
Instrument Panel & Indicators163
Turn Signal Lights, Lights and Horn164
Engine Coolant165
Air Cleaner (Dry Type)165
Cleaning of Radiator and Radiator Screen166
Tightening State of Bolts and Nuts of each Part167
Adjustment of Clutch Pedal Play (Mechanical Type)168
Adjustment of Brake Pedal Play169
Adjusting HST Control Linkage (HST Type)170
Every 50 Hour Check171
Lubricating Grease Nipple171
Cleaning of Radiator and Radiator Screen171
Checking Transmission Oil172
Checking Front Axle Oil172
Battery Check172
Air Cleaner (Dry Type)172
Hydraulic Hoses and Leakage173
Every 100 Hour Check174
Replacing Engine Oil and Filter175
Every 300 Hour Check175
Replacing Hydraulic Oil Filter176
Tension Adjustment of Engine Belt178
Toe-In178
Cleaning Fuel Tank179
Every 500 Hour Check180
Replacing Air Cleaner Element (Dry Type)181
Every 600 Hour Check182
Changing Front Axle Oil182
Changing Transmission Oil182
Every 1000Hr or 1-Year Check183
Adjusting Engine Valve Clearance183
Checking Nozzle Injection Pressure183
Every 1500Hr or 2-Year Check184
Replacing Engine Coolant184
Cleaning Emission Related Parts187
Every 3000Hr Check188
Cleaning Emission Related Parts188
General Maintenance (When Required)189
Air-Bleeding from Fuel System189
Fuse & Main Fuse191
Battery Handling and Notices193
Alternator and Drive Belt - Check197
Tail/Brake Light Bulb and Turn Signal Light Bulb- Replace198
Headlight Bulb - Replace200
Touch-Up Paint Color201
Troubleshooting202

LS tractor MT345E - Page 133

Table of Contents

Related product manuals