Home
LS tractor
Tractor
XR4140
LS tractor XR4140 User Manual
4
of 1
of 1 rating
252 pages
Give review
Manual
Specs
To Next Page
To Next Page
To Previous Page
To Previous Page
Loading...
1
-1
2
(6) T
ractor orientation
NOTE:
On this equipme
nt, left-hand and right-
hand are determine
d by standing behin
d the
unit, looking in the direction of travel.
Left-hand view
Re
ar view
Front view
Front
Rear
Right
Left
When reading this Operat
or's Manual, refer to
the right figure for the discrimination of
the
direct
ions.
25
27
Table of Contents
Table of Contents
9
General Notices for Safety
15
Note to the Owner - General Information
15
Before Using the Tractor
17
Manual Scope and Required Training Level
19
Metric and Imperial Units Abbreviations
21
Product Identification Number (PIN)
23
Operator's Manual Storage
25
Tractor Orientation
26
Safety Precautions (Read this for Safety before Using)
27
Notices before Using the Tractor
27
Notices When Starting Engine
31
Notices While Operating/Using the Tractor
32
Notices When Connecting Implement
34
Notices When Towing the Tractor
35
Notices When Transporting the Tractor
35
Notices When Servicing the Tractor after Work
36
Notices When Handling Diesel Fuel
37
Notices When Leaving the Tractor
38
Notices Relating to Toxic Substances
38
Tractor Stability
39
Ecology and the Environment
42
Symbols
44
Safety Decals
45
Instructional Decals
54
Long-Term Storage
59
Preparation for Storage
59
Check & Maintenance During Storage
60
Preparation for Reuse
61
Instruction for Safe Operation
63
The Name of each Part
63
Boarding and Exiting the Tractor
65
Boarding the Tractor
65
Driver's Seat (HST Type)
66
Seat Adjustment
67
Seat Belt
69
Tilting Steering Wheel
70
Ventilation (Cabin Only)
70
Exiting the Tractor
71
Safety Device
72
Hood (Bonnet)
72
Fender
72
PTO Safety Cover and Protection Cap
72
Roll-Over Protective Structure (ROPS)
73
Instruments and Controls
77
Instrument Panel and Front Controls
77
Instrument Panel
79
Key Switch
85
Turn Signal Light Switch
86
Light Switch
87
Hazard Warning Light Switch
88
Horn Switch
89
Grille Work Light Switch
89
DPF Switch
90
PTO Switch
95
PTO Mode Switch
95
Shuttle Lever (Mechanical Synchro-Shuttle)
96
Throttle Lever
96
Throttle Pedal (Mechanical)
97
Clutch Pedal (Mechanical)
97
Brake Pedals
98
Cruise Control Switch (HST Type)
99
HST Forward/Reverse Pedal (HST Type)
99
Creeper Gear Lever (MEC, if Fitted)
100
Right-Hand Controls and Cabin Pillar (Cabin Type)
101
Main Gear Shift Lever (Mechanical)
101
Range Gear Shift Lever (HST Type)
102
Parking Brake Lever
103
Differential Lock Pedal
103
Work Light Switch
104
Window Wiper Switch (Front, Rear)
104
Electrical Power Outlet Socket (Cabin Only)
105
Indoor Light (Cabin Only)
105
Audio Player (Cabin Only) (if Fitted)
105
ESC Main Switch
106
ESC Speed Up/Down Switch
106
Beacon Lamp Switch
107
Left-Hand Controls (Cabin Type)
108
Range Gear Shift Lever (Mechanical)
109
PTO Gear Lever (if Fitted)
109
Four Wheel Drive Lever (4WD)
110
Middle PTO Lever (if Fitted)
110
Ground Speed PTO(GSP) Lever (if Fitted)
111
Left / Right-Hand Controls (Roll-Bar Type)
112
Main Gear Shift Lever (Mechanical)
112
Range Gear Shift Lever (HST Type)
113
Parking Brake Lever
114
Differential Lock Pedal
114
ESC Main Switch
115
ESC Speed Up/Down Switch
115
Work Light Switch
116
Range Gear Shift Lever (Mechanical Only)
116
PTO Gear Lever (if Fitted)
117
Four Wheel Drive Lever (4WD)
117
Middle PTO Lever (if Fitted)
118
Ground Speed PTO(GSP) Lever (if Fitted)
118
Hydraulic System
119
Safety Precautions
119
Steering System
120
Hydraulic Lift Control (MHL) (Cabin Type)
120
Hydraulic Lift Control (MHL) (Roll-Bar Type)
122
Remote Control Lever and Quick Coupler (Optional)
125
Joystick Lever (if Fitted)
127
Hydraulic System Diagram
128
Operation and Work
131
How to Handle New Tractor
131
Check Points
131
Notices in Handling New Tractor (Engine Brake-In Procedure)
131
Engine Start and Stop
132
Engine Start
132
Start in Cold Weather
134
Engine Stop
135
How to Drive and Stop
136
Transmission Warm-Up in Cold Weather
136
How to Drive
137
Changing Speed
139
Emergency Stop
140
Stopping Tractor
141
Parking
142
Handling Turbocharger (if Fitted)
142
Transport on Public Roads
143
Safety Rules When Driving Tractor on the Roads
143
Light Operation
144
7-Pole Connector (Optional)
146
Notices When Towing the Tractor
147
Notices When Transporting the Tractor
149
Field Operations
150
Rear 3-Point Linkage
150
Power Take-Off (PTO) Operation
154
Hitch and Drawbar (Optional)
157
Technically Maximum Permissible Mass
158
Tires and Load Capacity
159
Adjusting Wheel Tracks and Tire Replacement
160
Using Front-End Loader (if Fitted)
161
Adjusting Steering Angle
164
Recommended Maximum Specification of Implements
165
Ballasting Weights (Optional)
166
Working in Hazardous Area
169
Driving Speed
170
Lubrication and Maintenance
173
General Information
173
Tightening Torque for Normal Assembly
174
Standard Torque Data for Hydraulics
176
General Specification - Diesel Fuel
179
Biodiesel Fuel
180
Refueling the Tractor
182
Change Engine Coolant to Organic Acid Technology (OAT) Coolant
183
Access for Maintenance
184
Maintenance Chart
185
Lubricants and Capacity
189
First 50 Hour Check
190
When the Warning Indicator Lights
191
Drain Water from Fuel Filter
191
Engine Oil Pressure Indicator
192
Battery Charging Indicator
192
Check before Starting (Daily Check)
193
Engine Oil
193
Fuel Tank
194
Instrument Panel & Indicators
194
Turn Signal Lights, Lights and Horn
195
Engine Coolant
196
Air Cleaner (Dry Type)
196
Cleaning of Radiator and Radiator Screen
197
Tire Air Pressure & Damage
197
Tightening State of Bolts and Nuts of each Part
198
Adjustment of Clutch Pedal Play (Mechanical Type)
199
Adjustment of Brake Pedal Play
200
Adjusting HST Control Linkage (HST Type)
201
Every 50 Hour Check
202
Lubricating Grease Nipple
202
Cleaning of Radiator and Radiator Screen
202
Checking Transmission Oil
203
Checking Front Axle Oil
203
Battery Check
203
Air Cleaner (Dry Type)
203
Hydraulic Hoses and Leakage
204
Cleaning Cabin Air Filters
204
Every 100 Hour Check
205
Checking and Adding Engine Oil
205
Every 300 Hour Check
206
Replacing Engine Oil and Filter
206
Replacing Hydraulic Oil Filter
207
Tension Adjustment of Engine Belt
208
Toe-In
208
Cleaning Fuel Tank
208
Every 500 Hour Check
209
Changing Front Axle Oil
209
Changing Transmission Oil
209
Replacing Fuel Filter Cartridge
210
Replacing Air Cleaner Element (Dry Type)
210
Replacing Cabin Air Filters
211
Every 1000Hr or 1-Year Check
212
Adjusting Engine Valve Clearance
212
Checking Nozzle Injection Pressure
212
Every 1500Hr or 2-Year Check
213
Replacement of Engine Coolant
213
Cleaning Emission Related Parts
216
Every 3000Hr Check
217
Cleaning Emission Related Parts
217
General Maintenance (When Required)
218
Air-Bleeding from Fuel System
218
Fuse & Main Fuse
220
Battery Handling and Notices
222
Alternator and Drive Belt - Check
226
Tail/Brake Light Bulb and Turn Signal Light Bulb- Replace
227
Headlight Bulb - Replace
229
Touch-Up Paint Color
230
Troubleshooting
231
Air Conditioning System (Cabin Type)
237
The Name of each Part of Cooling and Heating System
237
How to Use Air Conditioner and Heater
238
How to Operate Air Conditioner and Heater
238
Air Direction Control
238
Every 6 Month Check
239
Checking Refrigerant Amount
239
Cleaning Condenser and Radiator Screen
239
Checking Leakage
239
Belt Tension Adjustment
240
Cleaning and Replacing Cabin Air Filters
240
Every Year Check
241
Compressor Check
241
Control Switch Check
241
Troubleshooting
242
System Diagram
244
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the LS tractor XR4140 and is the answer not in the manual?
Ask a question
LS tractor XR4140 Specifications
General
Brand
LS tractor
Model
XR4140
Category
Tractor
Language
English
Related product manuals
LS tractor XR4150
252 pages
LS tractor XR4040H
104 pages
LS tractor XR3037H
104 pages
LS tractor XG3032
148 pages
LS tractor XU6158
234 pages
LS tractor XG3140
144 pages
LS tractor XG3037
148 pages
LS tractor XU6168
234 pages
LS tractor XG3025H
144 pages
LS tractor XG3140H
144 pages
LS tractor XG3135H
144 pages
LS tractor XG3037H
148 pages
To Next PageTo Next PageTo Previous PageTo Previous Page
Loading...
Need help?
General
