Massimo MSU 700 - Page 167

To Next Page

To Previous Page

10-7 Specifications

Model

HS700UTV-4

Speedometer ECU Normally energized

Stop lamp 、Turn lamp fuse

Gear switch fuse、 EPS fuse

Fuel pump fuse

Reverse gear fuse

Auxiliary DC jack fuse

ECU、Speedometer unit fuse

Four-wheel drive fuse

5.0A

10.0A

15.0A

10.0A

15.0A

Main Page

Introduction2
Important Manual Information4
Important Notice5
Contents6
Location of the Warning and Safety Labels10
Safety Information17
Description and Vehicle Identification22
Identification Number Records24
Vehicle Identification Number24
Control Functions25
Main Switch25
Indicator and Warning Lights26
Low-Range Indicator Light "L"27
Mechanical Parking Brake Indicator Light27
Neutral Indicator Light "N"27
Coolant Temperature Warning Light27
High Beam Indicator28
Position Light Indicator28
Emergency Indicator28
Use of EPS System28
Speedometer Unit29
Speedometer Unit Functions30
Odometer and Trip Meter Modes30
Clock Time Adjustment31
Four-Wheel Drive Indicator31
Differential Gear Lock Indicator31
Riding an UTV While the Differential32
Fault Code Indicator32
Fuel Level Indicator33
Switches34
On-Command Four-Wheel–Drive and Conditions35
Differential Gear Lock Switches35
On-Command Four-Wheel-Drive Switch "2WD/4WD"36
On-Command Differential Gear Lock Switch "4WD"/"LOCK"37
Accelerator Pedal38
Brake Pedal39
Parking Brake Lever40
Drive Select Lever41
Fuel Tank Cap41
Seats42
Seat Belts43
To Wear the Seat Belt Properly, Do the Following43
Glove Compartment45
Cargo Bed46
Opening and Closing the Tailgate46
Lifting and Lowering the Cargo Bed47
Front and Rear Shock Adjustment49
Standard Position50
Trailer Hitch Bracket51
Auxiliary DC Jack51
Pre Operation Checks53
Before Using this Vehicle, Check the Following Items53
Brakes54
Brake Fluid Level54
Brake Fluid Leakage55
Brake Operation55
Fuel56
Gasohol56
Engine Oil57
Coolant58
Final Gear Oil59
Differential Gear Oil59
Throttle Pedal60
Throttle Freeplay Inspection61
Throttle Freeplay Adjustment61
Steering Wheel Inspection62
Fittings and Fasteners62
Lights62
Tires63
How to Measure Tire Pressure64
Tire Wear Limit65
Starting the Engine in Low Temperatures66
Starting the Engine67
Warming up68
Drive Select Lever Operation and69
Driving in Reverse69
Shifting: Neutral to High and High to Low69
Shifting: Neutral to Reverse70
Parking on a Slope73
Vehicle Break-In Period74
Engine Break-In75
0-10 Hours75
10-25 Hours76
Brake System Break-In76
CVT Break-In (Clutches/Belt)76
Accessories76
Loading77
Maximum Loading Limit78
Driving Your Vehicle81
Getting to Know Your Vehicle81
How to Avoid the Hazard84
Learning to Operate Your Vehicle85
Turning Your Vehicle86
Operating Improperly in Reverse87
Braking88
Going Uphill88
Maximum Slope Angle89
Going Downhill90
Riding over Rough Terrain95
Riding in Brush or Wooded Areas97
Encountering Obstacles on the Trail97
Periodic Maintenance and Adjustment99
Periodic Maintenance Chart for the Emission Control System101
Periodic Maintenance and Adjustment101
General Maintenance and Lubrication Chart102
Hood to Open/To Close105
Console to Remove/To Install106
Engine Oil and Oil Filter Cartridge107
To Change the Engine Oil108
Checking the Final Gear Oil Level111
Changing the Final Gear Oil113
Checking the Differential Gear Oil Level114
Changing the Differential Gear Oil115
Checking the Coolant Level116
Changing the Coolant117
Axle Boots117
Spark Plug Inspection118
Removal118
Installation119
Cleaning the Engine Air Filter Element120
V-Belt Cooling Duct Check Hose124
V-Belt Case Drain Plug125
Cleaning the Spark Arrester125
Valve Clearance127
Front Brake Pad Check127
Rear Brake Pad Check128
Checking the Brake Fluid Level129
Observe These Precautions129
Brake Fluid Replacement130
Checking the Brake Pedal130
Parking Brake Lever Free Play Adjustment131
Brake Light Switch Adjustment133
Cable Inspection and Lubrication133
Brake Pedal and Accelerator Pedal134
Lubrication134
Steering Shaft Lubrication135
Wheel Removal136
Wheel Installation136
Battery137
Battery Maintenance139
Fuse Replacement139
Replacing a Headlight Bulb141
Tail/Brake Light Bulb Replacement144
Troubleshooting146
Solution to Common Problems in Vehicle148
Solution of Common Problems in Appearance Parts and Impact Fittings148
Solution of Common Problems in Brake System149
Solution of Common Problems in Electrical System151
Solution of Common Problems in Running System152
Solution of Common Problems in Engine System154
Cleaning157
Cleaning and Storage159
Specifications161
Fault Code of Electronic Injection System168

Massimo MSU 700 - Page 167

Table of Contents

Related product manuals