MDC FORBES 12+ - Page 90

www.marketdirect.com.au
I
Ph: 1300 494 494
I
©Copyright
I Page | 90
Every 6 MONTHS / 5,000KM SERVICE
CHECKED
Hitch
• Check hitch bolts to 90Nm
Handbrake
• Check cable and adjust if necessary
Hand winch
• Check brake function and webbing
Suspension
• Lubricate and check bushes for excess movement.
• Torque bolts to 190Nm
Brakes
• Inspect and adjust. Check lining thickness and drum wear
Wheel bearings
• Remove, clean and re-lubricate. Inspect for wear and replace if
necessary
Wheel Nuts
• Inspect condition and torque to 125Nm (12mm studs)
(140Nm 14mm studs alloy rims), (200Nm 14mm studs steel rims)
Tyres
• Inspect for abnormal wear, damage, and pressure
Lights
• Check all lights are functioning
Battery
• Check terminals and voltage at full charge
Seals
• Check condition and correct latch/lock adjustment for correct 30-
50% compression
General fixings
• Check all structural fixing are secure.
Seals & Latches
• Check all seals on doors and hatches compress 30-50%. All seals in
serviceable condition and free of damage.
Suspension
• Grease bushes and check for play.
• Check torque on suspension hanger bolts (190nm)
• Check retaining chain shackles tight.
Service Centre:
Notes:
________________________________________________________________________
________________________________________________________________________
________________________________________________________________________
________________________________________________________________________
________________________________________________________________________
________________________________________________________________________