Mitsubishi S6B Service Manual

CONTENTS-4
CONTENTS
List of illustrations
Fig. 2-1 Engine left view........................................... 2-1
Fig. 2-2 Engine right view......................................... 2-1
Fig. 2-3 Start switch and stop switch........................ 2-2
Fig. 2-4 Manual stop lever........................................ 2-2
Fig. 2-5 Stop solenoid .............................................. 2-2
Fig. 2-6 Oil pressure unit.......................................... 2-3
Fig. 2-7 Thermo unit................................................. 2-3
Fig. 2-8 Revolution detection pickup ........................ 2-3
Fig. 2-9 Oil pressure switch...................................... 2-4
Fig. 2-10Thermo switch ............................................ 2-4
Fig. 2-11Oil filter alarm switch .................................. 2-4
Fig. 2-12Overrun detection pickup............................ 2-5
Fig. 2-13Air cleaner indicator.................................... 2-5
Fig. 3-1 Priming pump - Handle ............................... 3-2
Fig. 3-2 Fuel filter - Bleed air ................................... 3-2
Fig. 3-3 Fuel injection pump - Bleed air.................... 3-2
Fig. 3-4 Priming pump cap tightening method.......... 3-3
Fig. 3-5 Priming pump head packing........................ 3-3
Fig. 3-6 Oil filler and oil level gauge ......................... 3-4
Fig. 3-7 Pouring engine oil on valve mechanisms
and chamber ............................................... 3-4
Fig. 3-8 Coolant drain cock (engine) ........................ 3-5
Fig. 3-9 Radiator coolant level.................................. 3-5
Fig. 3-10Reserve tank coolant level ......................... 3-5
Fig. 3-11Battery electrolyte level - Inspect................ 3-6
Fig. 3-12Specific gravity of battery electrolyte
- Check....................................................... 3-6
Fig. 3-13Valves for open/closed position - Check .... 3-8
Fig. 3-14Oil filler and oil level gauge......................... 3-9
Fig. 3-15Radiator cap ............................................. 3-10
Fig. 3-16Radiator coolant level............................... 3-10
Fig. 3-17Reserve tank coolant level ....................... 3-10
Fig. 3-18Fuel control link - Check........................... 3-10
Fig. 3-19Air tank - Drain water................................ 3-11
Fig. 3-20Air tank air pressure - Check.................... 3-11
Fig. 3-21Air cleaner - Check................................... 3-11
Fig. 3-22Thermo label of damper ........................... 3-12
Fig. 3-23Manual stop lever ..................................... 3-15
Fig. 4-1 Recommended fuel..................................... 4-1
Fig. 4-2 Recommended fuel according to ambient
temperature..................................................4-1
Fig. 5-1 Recommended engine oil ............................5-1
Fig. 5-2 Selection of oil viscosity...............................5-3
Fig. 5-3 Engine oil sampling tool set .........................5-6
Fig. 6-1 GLASSY - LLC.............................................6-1
Fig. 8-1 V-belt and belt tension
- Inspect and Adjust ....................................8-2
Fig. 8-2 Damper - Check visually..............................8-3
Fig. 8-3 Damper temperature management..............8-4
Fig. 8-4 Fuel tank - Drain water.................................8-5
Fig. 8-5 Fuel control linkage for looseness
- Inspect ......................................................8-6
Fig. 8-6 Fuel control linkage - Remove .....................8-6
Fig. 8-7 Water separator - Drain water......................8-7
Fig. 8-8 Water separator element - Replace.............8-7
Fig. 8-9 Gauze filter - Clean ......................................8-7
Fig. 8-10Fuel filter - Replace .....................................8-8
Fig. 8-11Fuel filter......................................................8-8
Fig. 8-12High pressure fuel injection pipe and
Clamp seat - Inspect and Replace...............8-9
Fig. 8-13Low pressure fuel pipe and Clip
- Inspect and Replace.................................8-9
Fig. 8-14Oil filler and oil level gauge........................8-10
Fig. 8-15Oil filter and bypass oil filter - Replace ......8-11
Fig. 8-16Governor oil filter - Replace.......................8-12
Fig. 8-17Oil pipe and Clip - Inspect and Replace ....8-12
Fig. 8-18Radiator cap ..............................................8-13
Fig. 8-19Coolant drain cock (engine).......................8-13
Fig. 8-20Radiator coolant level................................8-14
Fig. 8-21Reserve tank .............................................8-14
Fig. 8-22Radiator fins - Clean..................................8-14
Fig. 8-23Turbocharger - Inspect..............................8-15
Fig. 8-24Draining water from the exhaust muffler....8-15
Fig. 8-25Pre-cleaner - Clean ...................................8-16
Fig. 8-26Air cleaner element - Remove...................8-17
Fig. 8-27Air cleaner element - Clean and Check.....8-17
Fig. 8-28Air cleaner - Check....................................8-17
Fig. 8-29Battery electrolyte level - Inspect...............8-18
Fig. 8-30Specific gravity of battery electrolyte
- Check......................................................8-18

Mitsubishi S6B Specifications

General

Brand	Mitsubishi
Model	S6B
Category	Engine
Language	English