ODES Dominator - Page 96

- 95 -
ITEM
ROUTINE
Whichever
Comes first
→
INTIAL
EVERY
month
1
3
6
6
12
Km
(mi)
320
(200)
1,200
(750)
2,400
(1,500)
2,400
(1,500)
4,800
(3,000)
hours
20
75
150
150
300
Front brake*
●Check operation/brake pad wear/fluid leakage.
●Correct if necessary. Replace pads if worn to the limit.
○
○
○
○
○
Rear brake*
●Check operation/brake pad wear/fluid leakage.
●Correct if necessary. Replace pads if worn to the limit.
○
○
○
○
○
Accelerator pedal*
●Check operation and free play.
○
○
○
○
○
Wheels*
●Check balance/damage/ runout .
●Repair if necessary.
○
○
○
○
Wheel bearings*
●Check bearing assemblies for looseness/damage..
●Replace if damaged.
○
○
○
○
Front and rear
Suspension*
●Check operation and for leakage.
●Correct if necessary.
○
○
Steering system*
●Check operation and for looseness/Replace if damage.
●Check toe-in/Adjust if necessary.
○
○
○
○
○
Rear upper and lower knuckle pivots*
●Lubricate with lithium-soap-based grease.
○
○
○
Drive shaft universal joint*
●Lubricate with lithium-soap-based grease.
○
○
○
Engine mount*
●Check for cracks or damage.
●Correct bolt tightness.
○
○
○
Front and rear axle boots*
●Check operation.
●Replace if damage.
○
○
Stabilizer bushings*
●Check for cracks or damage.
○
○
○
Fittings and fasteners*
●Check all chassis fittings and fasteners.
●Correct if necessary.
○
○
○
○
○
NOTE:
● Recommended brake fluid: DOT4
● Brake fluid replacement:
● Replace the brake hoses every four years, or if cracked or damaged.
● When disassembling the master cylinder or caliper, replace the brake fluid.
Normally check the brake fluid level and add fluid as required.
● On the inner parts of the master cylinder and caliper, replace the oil seals every two years.