237Opel Service, maintenance
⊕ Additional work.
o The intervals are shorter where driving conditions are more arduous or country-specific.
Service work
after year
1)
km (x1000)
1)
1)
Depending on what occurs first.
1
15
2
30
3
45
4
60
5
75
⊕o
Remove brake drum, clean, carry out visual check every 4 years/60000 km
Visually inspect steering system boots, track rods, final drive xxxxx
Check track rod end and supporting ball joint xxxxx
⊕
Change brake and clutch fluids (manual transmission automated) every 2 years
Loosen wheel mountings and tighten to 110 Nm
xx
Grease or apply oil to bolt taper when fitting.
Check tyre condition and pressure (including spare wheel), correct if necessary.
If there is a tyre inflation system, check that the set is complete and the use-by date is
still valid. Replace sealant bottle every four years.
⊕
Annual service check if the annual distance travelled is greater than 20000 km.
Visually check the first aid kit (that it is where it should be, that it is undamaged and that
the use by date is still valid), lashing eyes and warning triangle
every 2 years
Check headlamp settings (including auxiliary headlamps), adjust if necessary x x
⊕o
Lubricate door hinges, check arms, cylinder lock, door latch, bonnet catch, rear panel
hinge
xx
OPC: check function of central locking system
clean door lock from outside and grease
xxxxx
Test run, final check (check steering and ignition lock, instrument and warning lamps,
entire brake system, steering, air conditioning system, engine, bodywork and chassis,
reset service/interval display with TECH 2.
xxxxx
To Next Page
Loading...
