PEERLESS SERIES 62

To Next Page

To Previous Page

ItemNo, PartNo. Description

JacketAssembly

TheraltimeterGauge

SteamGauge

Gauge GlassBet

3/4"DrainCock

LightingInstructionPlate

Lighting/OperatingInstructionsLabel

HighTemperatureSealingCement

1/2"Pint Can NippleSealer

1/4"AluminumTubing

WaterTrim

SteamTrimw/LWCO

GasValve

Pilot

IgnitionControl

LimitControl

GasControlAssembly

AdditionalInformation

SpecifyBoilerModel

SpecifyControlSystem

SpecifyQuantityof Containers

SpecifyQuantity

SpecifyQuantityin Feet

SpecifyBoilerModel,ControlSystem,Typeof Gas

SpecifyControlSystemandTypeof Gas

SpecifyModel

SpecifyBoilerModelandControlSystem

SpecifyControlSystem

Main Page

Features Series 612
Standard Equipment2
Optional Equipment2
Features Series 624
Control Locations6
Boiler Dimensions6
Cast Iron Block6
Cast Iron Section6
Piping Diagram7
Tankless Water Heater Ratings7
Series 62 Boiler Specs8
Accessibility Clearances9
Clearance from Combustible Construction9
Air for Combustion and Ventilation9
Setting up Boiler - Package Units9
Unassembled Units10
Assembled Blocks10
Jacket Assembly11
Split Block Assembly11
Wrap-Around Rear Jacket Panel Style11
Procedure for Stacking Pallets11
Individual Back Jacket Panel Style12
Side Panel Attachment12
Rear View Wrapper Style Jacket12
Rear View of Back Panel12
Agency Label and Plate Locations13
Front/Rear Boiler View14
Hook Bolt Assembly14
Flue Collector/Fraft Hood14
Side View of Inner Front and Cover Door14
Venting15
General15
Vent Damper Installation16
Venting Multiple Appliances16
Venting with Vent Damper in Vertical/Horizontal Position17
Piping18
Gas Piping18
Steam Header, Risers and Equalizer Sizing19
Steam Supply and Return Piping19
Hot Water Supply and Return Piping19
Parallel Hook-Up with Water Chiller20
Gas Connection to Boiler20
Gravity Hot Water20
Forced Hot Water20
Steam: Primary Probe LWCO21
Gauge/Pressuretrols Piping Arrangement21
Gauge/Pressuretrols Alternate Piping Arrangement21
Controls22
Steam22
Hot Water22
Probe LWCO Location for Hot Water Boiler22
Wiring23
Starting Boiler23
Burner Input24
Adjustment to Gas Pressure Regulator24
Adjustment of Pilot Gas Flow24
Number of Orifice Spuds Required24
Schematic Diagrams25
Steam W/Damper, Float LWCO and Isolation Relay25
Steam or Gravity Hot Water25
Gravity or Steam W/Damper, Float LWCO and Isolation Relay26
Forced Hot Water W/Damper26
Forced Hot Water W/Coil and Damper27
W/Dual 24V Main Gas Valves28
W/Dual 120V Main Gas Valves28
Wiring of Probe LWCO29
Steam W/Damper and Hydrolevel Probe LWCO30
Steam and Hydrolevel Probe LWCO30
W/Dual 24V Main Gas Valves and Hydrolevel Probe LWCO32
W/Dual 120V Main Gas Vlaves and Hydrolevel Probe LWCO32
Safety Instructions33
Lighting Instructions (Constant Burning Pilot)33
To Turn off Gas to Appliance33
Operating Instructions34
Lighting Instructions (Electric Ignition and Dual Gas Valve)35
HSP Control System and Ignition Control Box Location36
Operating Instructions (Electric Ignition and a Combination Gas Valve)37
HSP-2 Control System38
24 Volt Control System W/Dual Valves40
Instructions for Operation41
Check out Procedure41
Shut-Down Caused by Pilot Outage or Vent Safety Shut off Switch41
Shut-Down Caused by Flame Roll-Out Safety Shut off Switch41
Cleaning the Series 61/62 Steam Boiler with Skim Tapping42
Ratings, Tapping Locations and Dimensional Data43
Maintenance and Inspection45
Repair Parts46

PEERLESS SERIES 62 - Page 47

Table of Contents

Related product manuals