Perkins 2206F-E13TA - Page 118

Obtain the Sample and the Analysis ......... 100
Engine Operation ............................................ 50
Engine Operation and the Aftertreatment
System ....................................................... 50
Engine Operation with Active Diagnostic
Codes ............................................................ 41
Engine Operation with Intermittent
Diagnostic Codes .......................................... 42
Engine Starting.......................................... 15, 46
Engine Stopping ........................................ 15, 61
Engine Valve Lash - Check ........................... 102
F
Fault Logging................................................... 41
Features and Controls..................................... 34
Fire Prevention and Explosion Prevention...... 12
Ether ............................................................ 13
Fire Extinguisher.......................................... 13
Lines, Tubes, and Hoses ............................. 14
Fluid Recommendations ........................... 64, 75
ELC Cooling System Maintenance.............. 66
Engine Oil .................................................... 76
General Coolant Information ....................... 64
General Lubricant Information..................... 75
Fluid Recommendations (Diesel Exhaust
Fluid (DEF)) ................................................... 62
General Information..................................... 62
Fluid Recommendations (General Fuel
Information) ................................................... 68
Contamination Control Recommendations for
Fuels .......................................................... 75
Diesel Fuel Characteristics.......................... 71
Diesel Fuel Requirements ........................... 68
General Information..................................... 68
Foreword ........................................................... 4
California Proposition 65 Warning................. 4
Literature Information .................................... 4
Maintenance .................................................. 4
Maintenance Intervals ................................... 4
Operation ....................................................... 4
Overhaul ........................................................ 4
Safety............................................................. 4
Fuel and the Effect from Cold Weather........... 59
Fuel Conservation Practices ........................... 51
Fuel Related Components in Cold Weather ... 60
Fuel Heaters ................................................ 60
Fuel Tanks ................................................... 60
Fuel System - Prime...................................... 102
Fuel System Primary Filter (Water
Separator) Element - Replace..................... 103
Fuel System Primary Filter/Water Separator -
Drain ............................................................ 104
Fuel System Secondary Filter - Replace ...... 105
Fuel Tank Water and Sediment - Drain ......... 106
Drain the Water and the Sediment ............ 106
Fuel Storage Tanks.................................... 106
Fuel Tank ................................................... 106
Fumes Disposal Filter Element - Replace
(If Equipped) ................................................ 106
Element Service......................................... 107
G
General Hazard Information.............................. 8
Containing Fluid Spillage............................. 10
Diesel Exhaust Fluid.....................................11
Dispose of Waste Properly ...........................11
Fluid Penetration ........................................... 9
Inhalation ..................................................... 10
Pressurized Air and Water............................. 9
Static Electricity Hazard when Fueling with
Ultra-low Sulfur Diesel Fuel ....................... 10
General Information ........................................ 17
Grounding Stud - Inspect/Clean/Tighten....... 108
H
Hoses and Clamps - Inspect/Replace........... 109
Fuel System............................................... 109
Replace the Hoses and the Clamps .......... 109
I
Important Safety Information............................. 2
Injector (Diesel Exhaust Fluid) - Replace.......110
L
Lifting and Storage .......................................... 27
M
Maintenance Interval Schedule....................... 81
Daily ............................................................. 81
Every 10 000 Service Hours........................ 82
Every 12 000 Service Hours or 6 Years....... 82
Every 2000 Service Hours........................... 81
Every 2000 Service Hours or 1 Year ........... 81
Every 250 Service Hours............................. 81
Every 2500 Service Hours........................... 81
Every 3000 Service Hours or 2 Years ......... 81
Every 4000 Service Hours........................... 81
Every 492 100 L (130 000 US gal) of Fuel .. 82
118
SEBU9071-01
Index Section