Perkins 854F-E34T - Indexsection; Index

Index
A
Acceleration Is Poor or Throttle Response
Is Poor............................................................ 31
Probable Causes ......................................... 31
Recommended Actions................................ 31
Alternator Problem (Charging Problem and/
or Noisy Operation)........................................ 34
Probable Causes ......................................... 34
Recommended Actions................................ 34
B
Battery Problem............................................... 36
Probable Causes ......................................... 36
Recommended Actions................................ 36
C
Circuit Tests ................................................... 121
Component Location ....................................... 10
C3.4B Engine............................................... 13
Clean Emissions Module (CEM).................. 18
Electronic Control Circuit Diagram............... 10
Configuration Parameters................................ 22
Coolant Contains Oil........................................ 37
Probable Causes ......................................... 37
Recommended Actions................................ 37
Coolant Level Is Low ....................................... 38
Coolant Temperature Is High........................... 38
Probable Causes ......................................... 39
Recommended Actions................................ 39
Crankcase Breather Ejects Oil ........................ 42
Probable Causes ......................................... 43
Recommended Actions................................ 43
Cylinder Is Noisy.............................................. 45
Probable Causes ......................................... 45
Recommended Actions................................ 45
D
Data Link - Test.............................................. 121
Diagnostic Capabilities .................................... 19
Diagnostic Codes......................................... 19
Diagnostic Trouble Codes ............................... 23
Operator Inducement Codes........................ 29
Diesel Particulate Filter Active
Regeneration Occurrence Is Excessive ........ 46
Probable Causes ......................................... 46
Recommended Actions................................ 46
Diesel Particulate Filter Active
Regeneration Was Interrupted....................... 48
Recommended Actions................................ 48
Diesel Particulate Filter Collects Excessive
Soot ............................................................... 49
Probable Causes ......................................... 50
Recommended Actions................................ 50
Diesel Particulate Filter Has Differential
Pressure Problem.......................................... 51
Probable Causes ......................................... 52
Recommended Actions................................ 52
Diesel Particulate Filter Regeneration............. 19
Regeneration ............................................... 19
Diesel Particulate Filter Temperature Is Low ... 54
Probable Causes ......................................... 54
Recommended Actions................................ 54
E
ECM - Replace .............................................. 242
ECM Memory - Test ....................................... 124
ECM Software - Install................................... 241
Flash Programming a Flash File ................ 241
Electrical Connectors....................................... 20
Connectors for the Electronic Control Module
(ECM)......................................................... 20
Electrical Connectors - Inspect...................... 243
Electrical Power Supply - Test ....................... 127
Electronic Service Tool Does Not
Communicate............................................... 239
Probable Causes ....................................... 239
Recommended Actions.............................. 239
Electronic Service Tools .................................... 6
Optional Service Tools ................................... 7
Perkins Electronic Service Tool..................... 7
Required Service Tools.................................. 7
Electronic System Overview.............................. 9
Engine Cranks but Does Not Start................... 55
Probable Causes ......................................... 55
Recommended Actions................................ 55
Engine Does Not Crank................................... 60
Probable Causes ......................................... 60
Recommended Repairs............................... 60
Engine Has Early Wear ................................... 62
Probable Causes ......................................... 62
Recommended Actions................................ 62
Engine Has Mechanical Noise (Knock) ........... 64
Probable Causes ......................................... 64
248 UENR0612
Index Section
This document has been printed from SPI2. NOT FOR RESALE