2
9850064 R03 - 2021 650 / 850 Matryx Trail Performance / Crossover Snowmobile Service Manual
© Copyright Polaris Inc.
2.11
XU - PERFORM THESE PROCEDURES MORE OFTEN FOR VEHICLES SUBJECTED TO SEVERE USE.
D - HAVE AN AUTHORIZED POLARIS DEALER PERFORM THESE SERVICES.
E - EMISSION CONTROL SYSTEM SERVICE.
CODE ITEM ACTION
Ignition Timing BTDC Inspect or Adjust
Spark Plugs Inspect or Adjust
Exhaust System Retaining Springs Inspect or Adjust
50/50 Extended Life Coolant
Replace every 5 years
60/40 Coolant (If applicable) Replace every 2 years
Cooling Hoses / Pipes Inspect or Adjust
Hose Condition / Routing Inspect or Adjust
Fluid Level / Leaks / Fluid Condition
Inspect or Adjust
Brake Pads / Brake Disc
Inspect or Adjust
Throttle Lever / Throttle Cable
Inspect or Adjust
Fuel / Vent Hoses
Inspect or Adjust
Air Box
Inspect or Adjust
Ski Toe Alignment Inspect or Adjust
Hood / Side Panel Fasteners
Inspect or Adjust
Drive Chain Tension (If Equipped) Inspect or Adjust
Chaincase Oil (If Equipped) Replace
Track Alignment / Track Tension Inspect or Adjust
Front Limiter Strap Inspect or Adjust
Rail Slide Condition
Inspect or Adjust
Bogie / Wheel Condition / Fastener
Bolts
Inspect or Adjust
Rear Idler Wheel Bolts
Inspect or Adjust
Rear Idler Adjuster Bolt Jam Nuts Inspect or Adjust
Cooling Fins and Shroud Inspect or Adjust
Camber Alignment Inspect or Adjust
Hood / Seat / Chassis / Engine
Compartment
Clean
1000 MILES (1600 KM) SERVICE
XU - PERFORM THESE PROCEDURES MORE OFTEN FOR VEHICLES SUBJECTED TO SEVERE USE.
D - HAVE AN AUTHORIZED POLARIS DEALER PERFORM THESE SERVICES.
E - EMISSION CONTROL SYSTEM SERVICE.
CODE ITEM ACTION
Clutch Alignment / Offset Inspect or Adjust
QUICKDRIVE Belt (If Equipped) Inspect or Adjust
MAINTENANCE
To Next Page
Loading...
Need help?
General
