56
MAINTENANCE AND LUBRICATION
Periodic Maintenance Schedule
Item Frequency Remarks
J Brake pad wear 25 hrs Inspect periodically
"
L
Engine breather filter 25 hrs Inspect, replace annually and as
needed
" General Lubrication 25 hrs Lubricate all fittings, pivots, cables
Engine Cylinder
Head/Cylinder Base
Fasteners
25 hrs Re-torque required at first service
only
" Engine Oil - Level 25 hrs Check level daily; break-in service
at 25 hours.
"
L
Engine Oil - Change
(4-Cycle)
100 hrs Change oil at 100 hours, more often
in cold weather use.
"
L
Oil Filter 100 hrs Replace with oil change
L Engine breather
hose
100 hrs Inspect
Carburetor Float
Bowl
50 hrs Drain bowl periodically and prior to
storage
J Throttle Cable 50 hrs Inspect; adjust, lubricate, replace if
necessary
L Choke (Enricher)
Cable
50 hrs Inspect; adjust, lubricate, replace if
necessary
Shift linkage 50 hrs Inspect; adjust
J Drive belt 50 hrs Inspect; adjust, replace if necessary
J Steering 50 hrs Inspect; lubricate
" Front Suspension 50 hrs Inspect; lubricate, tighten fasteners
" Rear Suspension 50 hrs Inspect, tighten fasteners
Improperly performing the procedures marked with a J could result
in component failure and lead to serious injury or death. Have an
authorized Polaris dealer perform these services.
WARNING
To Next Page
Loading...
Need help?
General
