Record Power BS250 - Dust Extraction; Importance of Dust Extraction; Record Power Dust Extractors

22 23
9. Dust Extraction
9.1 The importance of dust extraction
Before the machine is started, ensure that adequate dust
extraction provisions have been installed. Dust extraction is
extremely important not only for health and safety but also
for the correct upkeep of the machine. Saw dust can cause
the machine not to operate properly or even fail completely. It
is paramount that the extraction port is kept free of waste so
mounds of sawdust do not build up around the lower band
wheel and blade guides. It is advisable before starting the
machine to inspect the internals of the machine and ensure
there isn’t excessive dust build up. By keeping the machine free
of large amounts of waste the performance will be enhanced.
Even with adequate extraction there will be partial build up of
dust inside the machine, this should be cleaned out as part of
the regular maintenance schedule.
If a large amounts of MDF or toxic woods are to be cut we
recommend that there is a good ventilation system in place and
that a P2 particle mask is worn as minimum protection
.
9.2 Record Power Extractors
Record Power offer a range of high quality dust extractors,
starting at the single motor 45 litre RSDE1 right up to the 200
litre twin motor DX5000. We offer both drum and bag type
extractors and all models provide high filtration down 0.5 micron
providing protection from harmful fine dusts such as MDF.
RSDE1 High Filtration Dust Extractor
Drum type extractor, 45 litre capacity, single 1kw motor, suitable
for intermittent use i.e must be switched off for 20 minutes per
hour.
RSDE2 High Filtration Dust Extractor
Drum type extractor, 50 litre capacity, single 1kw motor, suitable
for intermittent use i.e must be switched off for 20 minutes per
hour.
RSDE3 High Filtration Dust Extractor
Bag type extractor, 80 litre capacity, single 1kw motor, suitable
for intermittent use i.e must be switched off for 20 minutes per
hour.
DX4000 High Filtration Dust Extractor
Drum type extractor, 80 litre capacity, Twin 1kw motor, suitable
for heavy usage i.e if one motor is switched off for 20
minutes
then the other can be used thus enabling continuous usage.
Or both motors can be used simultaneously giving maximum
suction but in this mode the extractor must be switched off for
20 minutes every hour.
DX5000 High Filtration Dust Extractor
Bag type extractor, 200 litre capacity, Twin 1kw motor, suitable
for heavy usage i.e if one motor is switched off for 20
minutes
then the other can be used thus enabling continuous usage.
Or both motors can be used simultaneously giving maximum
suction but in this mode the extractor must be switched off for
20 minutes every hour.
RSDE1 RSDE2 RSDE3 DX4000 DX5000
Bandsaws
Circular saws
Sanders
Intermittent usage
Bandsaws
Circular saws
Sanders
Heavy usage
Planer Thicknessers
Spindle Moulders
Universals
Intermittent usage
Planer Thicknessers
Spindle Moulders
Universals
Heavy usage
Dust Extraction
System
Intermittent usage
✓
Recommended
✓
Recommended
✓
Recommended
✓
Recommended
✓
Recommended
✓
Recommended
✓
Recommended
✓
Can be used
✓
Can be used
✓
Can be used
✓
Can be used
✓
Recommended
✓
Recommended
✓
Recommended