Name: SAME SOLARIS 45
Brand: SAME
Rating: 5 (1 reviews)

To Next Page

To Previous Page

SECTION III USE

Controls located to the right of the driver

The easily-identifiable controls are arranged so that the most important

ones are nearest the driver.

A - Auxiliary control valve controls

B - Front PTO controls

C - Rear lift controls

D - Rocker switch for supplementary rear hydraulics

(light blue)

CAUTION: TRAVELLING ON ROAD, USE THE ACCELERATOR

PEDAL ONLY AND NOT THE HAND THROTTLE LEVER.

Preface2
- Table of Contents3
Important10
SECTION 1 - Safety15
Aword to the Operator16
Introduction to Safety16
- Safety16
- A Word to the Operator16
- Danger, Warning, Caution16
Danger, Warning, Caution18
- Follow a Safety Programme18
  - For Safe Operation18
- General Safety Rules18
Follow a Safety Programme18
General Safety Rules24
- Protective Structures24
  - Roll over Protective Structures24
  - Operation24
Protective Structures24
Damage to the ROPS25
- Cab25
Cab26
- Prepare for Safe Operation26
Prepare for Safe Operation26
Servicing the Tractor31
- Starting31
- General Operating Hazards39
Starting31
General Operating Hazards40
- Safety and Operational Decals46
- International Symbols (Part. 1)58
International Symbols (Part. 1)59
- International Symbols (Part. 2)59
International Symbols (Part. 2)60
- International Symbols (Part. 3)60
International Symbols (Part. 3)61
- Metric Conversion61
Metric Conversion62
- Conversion Tables62
SECTION 2 - Replacement Parts65
- Tractor Serial Number65
Tractor Serial Number66
- Engine Serial Number66
- Tractor Identification Plate66
Engine Serial Number66
Tractor Identification Plate67
- Original Replacement Parts67
SECTION 3 - Use69
- Checking the Tractor Prior to Starting Work69
  - Refuelling70
  - Checking the Engine Oil Level71
Checking the Tractor Prior to Starting Work70
- Access to the Driving Position72
Access to the Driving Position73
- Lights' Switch73
Lights' Switch74
- Instrument Panel74
Instrument Panel75
- Ignition Switch80
Ignition Switch81
- Engine81
  - Precautions for Optimum Engine Performance81
- Starting the Engine83
  - Electronic Control of Engine Cooling System84
Engine81
Starting the Engine84
- Engine Shut down85
Engine Shut down86
- Cold Starting86
Cold Starting87
- Emergency Starting through Auxiliary Battery87
Emergency Starting through Auxiliary Battery88
- Turbocharging88
Turbocharging89
- Manual Emergency Stop89
Manual Emergency Stop90
- Adjusting the Driver's Seat90
  - BOSTROM Minibaltic XH2 Seat with Spring Suspension90
  - KAB P4 XH2 Sprung Seat91
- Adjusting the Rearview Mirrors93
Adjusting the Driver's Seat90
Adjusting the Rearview Mirrors94
- Control Pedals94
- Gearbox Controls99
  - Transmission Speed Selection100
Control Pedals94
Gearbox Controls100
- Front and Rear Differential Lock101
Front and Rear Differential Lock102
- Front-Wheel Drive102
Front-Wheel Drive103
- Power Take-Off103
Power Take-Off104
- Load Sensing - Mechanical Lift109
  - Controls110
  - Hydraulic System114
Load Sensing - Mechanical Lift110
- Auxiliary Hydraulic Services Control Valve117
Auxiliary Hydraulic Services Control Valve118
- Nomenclature118
- Types of Auxiliary Hydraulic Service Control Valve119
- The Controls120
- Example Connection and Operation of a Double-Acting Cylinder122
- Connection of an Implement to the Auxiliary Hydraulic Service Couplers123
- Converting a Control Valve from Double-Acting to Single-Acting126
- Example of Connection to a Single-Acting Cylinder127
Class "A" Drawbar128
- Towing Hitch129
Towing Hitch130
- Class "C" Towing Hitch130
- CEE Towing Hitch131
CEE Towing Hitch133
- Three-Point Linkage133
Three-Point Linkage134
- Hydraulic Front Lift137
  - Bodywork139
  - Safety Frame140
Hydraulic Front Lift139
- Cab142
Cab143
- Active Carbon Air Filter153
Active Carbon Air Filter154
- Cable Channel for Passing External Implement Control154
- Cables into the Cab154
- Hazard Warning Triangle154
- Screen Wash Liquid Reservoir154
SECTION 4 - Wheels155
- Track Adjustment155
- Tyre Inflation Pressures156
- Width of the Front Axle (Without Wheels)157
- Mechanical Ratio (Front Wheel Revolutions / Rear Wheel Revolution)157
- Width of Rear Axle (Without Wheels)157
- Row Crop Tires157
- Running Direction of Tires158
- Adjusting Steering Stops158
- Adjustable Track Wheels159
- Permissible Tyre Combinations160
Track Width Adjustment for Wheels with Adjustable Rims161
- Track Width Adjustment for Wheels with Fixed Rims168
Track Width Adjustment for Wheels with Fixed Rims169
- Ballast169
Ballast169
SECTION 5 - Maintenance Operations173
- Lubricants and Fluids175
Lubricants and Fluids176
- Maintenance Intervals176
Maintenance Intervals178
- Maintenance and Inspection Schedule178
Maintenance and Inspection Schedule181
- Fuel Storage181
  - Refueling181
  - Refueling at the End of the Day182
- Engine Maintenance183
Fuel Storage181
Engine Maintenance184
- Air Filter194
Air Filter195
- Cleaning the Air Filter195
Cleaning the Air Filter197
- Engine Cooling System197
- Adjusting Belt Tension200
Engine Cooling System197
Adjusting Belt Tension201
- Gearbox Clutch201
- Rear and Underside P.T.O. Clutch201
Gearbox Clutch201
Rear and Underside P.T.O. Clutch202
- Maintenance of the Gearbox, Differential and Rear Reduction Units202
  - Checking the Transmission Oil Level204
  - Changing the Oil205
Maintenance of the Gearbox, Differential and Rear Reduction Units204
Maintenance of the Hydrostatic Power Steering206
- Checking Operation of the Differential Lock Controls207
Checking Operation of the Differential Lock Controls208
- Maintenance of the Front and Rear Brakes208
  - Checking the Braking Action208
- Front Differential Lock (if Installed)208
Maintenance of the Front and Rear Brakes208
Front Differential Lock (if Installed)209
- Maintenance of the Front Wheel Drive System209
  - Front Axle and Hub Final Drives (4WD)209
  - Front Axle Pivot Bushes209
Maintenance of Hydraulic Power-Lift211
- Maintenance of the 3-Point Linkage211
  - Rear 3-Point Linkage211
- Maintenance of Front P.T.O212
Maintenance of the 3-Point Linkage211
Maintenance of Front P.T.O.213
- Maintenance of Front Lift213
Maintenance of Front Lift214
- Windscreen Washer214
- Windscreen and Rear Screen Wipers214
Windscreen Washer214
Windscreen and Rear Screen Wipers215
- Maintenance of the Air Conditioning System215
  - Cab Air Filter (Cleaning)215
  - Active Carbon Air Filter215
- Maintenance of the Heating System216
Maintenance of the Air Conditioning System215
Maintenance of the Heating System217
- Maintenance of the Air Conditioning System217
Maintenance of the Air Conditioning System217
General Cleaning of the Tractor220
- Cleaning with Compressed Air220
Cleaning with Compressed Air221
SECTION 6 - Electrical System221
- Battery221
  - Checking the Battery221
- Fuse Box223
Battery221
Fuse Box226
Cab Fuse Box232
Lights236
- Headlight Alignment241
Headlight Alignment242
- Horizontal Adjustment242
- Vertical Adjustment242
SECTION 7 - Storage of the Tractor243
- Operations Prior to Garaging the Tractor for a Long Period243
Operations Prior to Garaging the Tractor for a Long Period244
- Preparing the Tractor for Use after a Long Period of Storage244
Preparing the Tractor for Use after a Long Period of Storage245
SECTION 8 - Technical Specifications245
- Engine245
Engine246
- Clutch246
- Power Take-Off246
Clutch246
Power Take-Off248
- Gearbox248
Gearbox249
- Gearbox Ratios Schematic249
Gearbox Ratios Schematic250
- Performance - Ground Speed in Km/H (Mph) @ 3000 Rpm250
Performance - Ground Speed in Km/H (Mph) @ 3000 Rpm252
- Front Driving Axle252
- Hydrostatic Steering System252
- Front Hydraulic Lift252
Front Driving Axle252
Hydrostatic Steering System252
Front Hydraulic Lift253
- Hydraulic Diagram of Lift253
Hydraulic Diagram of Lift254
- Hydrostatic Steering System254
- Cab254
Hydrostatic Steering System254
Cab255
- Dimensions and Weights255
Dimensions and Weights256
- Unladen Weight of Tractor (Without Ballast)256
- Unladen Weight of Tractor (with Ballast)256
Unladen Weight of Tractor (Without Ballast)256
Unladen Weight of Tractor (with Ballast)257
- Maximum Permissible Loads257
- Maximum Trailerable Loads257
- Ballast Weights257
Maximum Permissible Loads257
Maximum Trailerable Loads257
Ballast Weights258
- Attachment of Implements to the Tractor258
Attachment of Implements to the Tractor259
- Implement Attachment Points259
Implement Attachment Points263
SECTION 9 - Fault Diagnosis263
- Engine263
Engine265
- Gearbox265
Gearbox266
- Rear Power Take-Off266
- Front Driving Axle266
- Brakes266
- Hydraulic Lift266
Rear Power Take-Off266
Front Driving Axle266
Brakes266
Hydraulic Lift267
- Auxiliary Hydraulic Systems267
Auxiliary Hydraulic Systems269
Appendix269
- Combination of Tractor and Mounted Implement269
Combination of Tractor and Mounted Implement270
- Determination of the Total Weight, the Axle Loads, the Tyre Load Carrying Capacity and the Necessary Minimum Ballasting270
- Consideration of Rear Mounted Implement and Front/Rear Combinations271
- Front Mounted Implement271

Questions and Answers:

Need help?

Do you have a question about the SAME SOLARIS 45 and is the answer not in the manual?

SAME SOLARIS 45 Specifications

General

Engine Power	45 hp
Hydraulic System	Open center
Drive	4WD
PTO Power	38 hp
Hydraulic Remotes	2
Engine Type	Diesel
PTO	540 rpm
Displacement	2.9 liters
Tire Size - Front	7.5-16

Related product manuals

SAME SOLARIS 45 User Manual

Table of Contents

Questions and Answers:

SAME SOLARIS 45 Specifications

Related product manuals