Snorkel S1930E - Default Chapter; Table of Contents

S1930E/S1932E/S2632E – 1360460
Table of Contents
Electrical Danger .............................. inside front cover
Proposition 65 Warning .................... inside front cover
Table of Contents
Chapter 1 – Introduction
Aerial Platform Features .............................................1
Options .......................................................................1
Operator’s Manual ......................................................1
Safety Alerts ...............................................................1
Operation ....................................................................1
Maintenance ...............................................................2
Manual of Responsibilities ..........................................2
Additional Information .................................................2
Chapter 2 – Specications
Component Identication ............................................3
General Specications – S1930E ...............................4
Aerial Platform .........................................................4
Platform ...................................................................4
Function Speed .......................................................4
Drive System ...........................................................4
Drive/Lift Level Sensor Interlock .............................4
Tires ........................................................................4
Electrical System .....................................................4
Hydraulic System ....................................................4
Ambient Air Temperature Operating Range ............4
Maximum Wind Speed ............................................4
General Specications – S1932E ...............................5
Aerial Platform .........................................................5
Platform ...................................................................5
Function Speed .......................................................5
Drive System ...........................................................5
Drive/Lift Level Sensor Interlock .............................5
Tires ........................................................................5
Electrical System .....................................................5
Hydraulic System ....................................................5
Ambient Air Temperature Operating Range ............5
Maximum Wind Speed ............................................5
General Specications – S2632E ...............................6
Aerial Platform .........................................................6
Platform ...................................................................6
Function Speed .......................................................6
Drive System ...........................................................6
Drive/Lift Level Sensor Interlock .............................6
Tires ........................................................................6
Electrical System .....................................................6
Hydraulic System ....................................................6
Ambient Air Temperature Operating Range ............6
Maximum Wind Speed ............................................6
Chapter 3 – Safety
Electrocution Hazards ................................................7
Minimum Safe Approach Distance .............................7
Prestart Inspection......................................................8
Work Place Inspection and Practices .........................8
Operation ....................................................................8
Tip-Over and Falling Hazards .....................................8
Electrical System ........................................................9
Hydraulic System........................................................9
Placards and Decals...................................................9
Chapter 4 – Safety Devices
Emergency Stop Controls......................................... 11
Drive Motion Alarm ................................................... 11
Pothole Protector Skids ............................................ 11
Drive/Lift Pothole Protector Interlock ........................12
Drive/Lift Level Sensor Interlock ...............................12
Lowering Alarm .........................................................12
Emergency Lowering System ...................................12
Safety Prop ...............................................................12
Guardrails .................................................................13
Ground Fault Circuit Interrupter ................................13
Tilt Alarm ...................................................................13
Horn ..........................................................................13
Flashing Light ...........................................................13
Chapter 5 – Gauges and Displays
Hour Meter................................................................15
Battery Charge Indicator ..........................................15
Battery Condition Indicator .........................................1
Chapter 6 – Batteries
General Maintenance ...............................................17
Charging ...................................................................17
Chapter 7 – Controls
Battery Disconnect ...................................................19
Lower Controls .........................................................19
Emergency Stop Button ........................................19
Control Selector Switch .........................................19
Platform Raise/Lower Switch ................................19
Upper Controls .........................................................20
Emergency Stop Button ........................................20
Drive/Lift Selector Switch ......................................20
Joystick .................................................................20
Interlock Switch .....................................................21
Steer Switch ..........................................................21
Drive Range Switch – S2632 Only ........................21
Horn Button ...........................................................21
Battery Condition Indicator ....................................21
Circuit Breaker Reset Button ....................................21
Chapter 8 – Prestart Inspection
Operator’s Manual ....................................................23
Electrical System ......................................................23
Battery Fluid Level ................................................23
Battery Terminals ...................................................24
Battery Charger .....................................................24
Safety Prop ...............................................................24
Cables and Wiring Harness ......................................25
Hydraulic System......................................................25
Fluid Level .............................................................25
Hoses, Tubes, and Fittings ....................................25
Free-Wheeling Valve .............................................25
Tires and Wheels ......................................................26