Sony CDP-C701ES User Manual

SERVICE MANUAL
SPECIFICATIONS
Compact Disc Player
System Compact disc digital audio system
Laser Semiconductor laser
Wavelength 780 - 790 nm
Frequency response = 2: Hz - 20 kHz (+0.3 dB)
Signal to noise ratio More than 116 dB
Dynamic range More than 100 dB
Harmonic distortion Less than 0.0023% (1 kHz)
Channel separation More than 110 dB (1 kHz)
Outputs
LINE OUT (FIXED) Output level 2 V (at 50 kilohms, non-DSP
(phono jacks) mode)
Load impedance over 10 kilohms
LINE OUT (VARIABLE) Output level max. 2 V (at 50 kilohms,
(phono jacks) non-DSP mode)
Load impedance over 10 kilohms
DIGITAL OUTPUT Wave length 660 nm
(OPTICAL) Output level -18 dBm
(optical output
connector)
PHONES Output level max. 15 mW
(stereo phone jack) Load impedance 32 ohms
General
Power requirements US, Canadian model: 120 V AC, 60 Hz
AEP model: 220—230 V AC, 50/60 Hz
E model: 110—120 V or 220—240 V
AC adjustable, 50/60 Hz
Power consumption 23 W
Dimensions (w/h/d) Approx. 470 x 125 x 385 mm
(18 5/8 x 5 x 15 1/4 inches)
Including projecting parts and controls
Mass (approx.) CDP-C801ES 9.1 kg (20 Ibs 1 02)
CDP-C701ES 8.7 kg (19 Ibs 3 oz)
Model Name Using Similar Mechanism
Optical Pick-up Block Type
CDP-C7O1ES/C8OIES
US Model
CDP-C701ES/C801ES
Canadian Model
AEP Model
E Model
CDP-C701ES
COMPACT
DIGITAL AUDIO
NEW
BU-5BD11
Remote Commander RM-D801
Remote control system Infrared control
Power requirements 3 V DC with two size AA batteries
(IEC designation R6)
Dimensions 62 x 20 x 175 mm (w/h/d)
(2 1/2 x 13/16 x 7 inches)
Mass (approx.) 130 g including batteries
(4.6 0z)
Design and specifications are subject to change without notice.
SAFETY-RELATED COMPONENT WARNING!!
COMPONENTS IDENTIFIED BY MARK A OR DOTTED
LINE WITH MARK A ON THE SCHEMATIC DIAGRAMS
AND IN THE PARTS LIST ARE CRITICAL TO SAFE
OPERATION. REPLACE THESE COMPONENTS WITH
SONY PARTS WHOSE PART NUMBERS APPEAR AS
SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB-
LISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT
A LA SECURITE!
LES COMPOSANTS IDENTIFIES PAR UNE MARQUE /\
SUR LES DIAGRAMMES SCHEMATIQUES ET LA LISTE
DES PIECES SONT CRITIQUES POUR LA SECURITE
DE FONCTIONNEMENT. NE REMPLACER CES COM-
POSANTS QUE PAR DES PIECES SONY DONT LES
NUMEROS SONT DONNES DANS CE MANUEL OU
DANS LES SUPPLEMENTS PUBLIES PAR SONY.
COMPACT DISC. PLAYER
SONY.

Sony CDP-C701ES Specifications

General

Type	CD Player
Frequency Response	2 Hz - 20 kHz
Signal-to-Noise Ratio	110 dB
Total Harmonic Distortion	0.0025%
Output Level	2.0 V
Digital converter	1-bit D/A converter
Digital outputs	Coaxial, Optical
Accessories	Remote control
Channels	2
Disc format	CD

Summary

SPECIFICATIONS

Compact Disc Player Specifications

Detailed technical specifications for the CD player's system, outputs, and general features.

Similar Mechanism Model Information

Lists models using a similar mechanism and their associated components.

Safety Related Component Warning

Critical Component Identification

Identifies critical safety components requiring specific Sony part replacements.

Handling and Checking Procedures

Optical Pick-up Block Handling

Precautions for handling the optical pick-up block to prevent electrostatic damage.

Laser Diode Emission Check

Guidelines for safely checking the laser diode emission from a safe distance.

Transit Key and Red Lock Screw Usage

Instructions for using and storing the transit key and red lock screw for transportation.

Safety Checks and Model Identification

Safety Check-out and Leakage Test

Procedures for performing safety checks and AC leakage tests on US models.

Model Identification Label Information

Information on identifying the model and its specification label.

General Information and Parts Identification

Identifying Unit Parts

Identifies front panel and remote commander parts with numerical references.

Disassembly Procedures

Bottom Plate Removal

Step-by-step instructions for removing the bottom plate of the unit.

Front Panel Disassembly

Instructions for disassembling the front panel in two parts.

Tray Assembly Disassembly

Procedure for disassembling the tray assembly.

Electrical Block Checking

RF Signal and Waveform Checks

Procedures for checking RF level, S curve, and E-F balance waveforms.

RF PLL Frequency Check

Procedure for checking the RF PLL free-run frequency.

Diagrams and Layouts

Circuit Board Locations

Diagram showing the location of various circuit boards within the unit.

Block Diagram and Signal Flow

Block diagram illustrating the signal flow and major functional blocks.

Printed Wiring Board Layouts

Printed wiring board layout for the main section.

Semiconductor Lead Layouts

Lead pin-out diagrams for various semiconductor components.

IC Block Diagrams

Specific IC Block Diagrams

Block diagrams illustrating the internal functions of key IC chips.

Exploded Views

Cabinet Section Views

Exploded views of the cabinet assembly for C801ES and C701ES models.

Front Panel Section

Exploded view of the front panel assembly and its components.

Chassis and Tray Sections

Exploded views of the chassis and tray assemblies.

Optical Pick-up Block

Exploded view of the optical pick-up block assembly.

Electrical Parts List

Component Lists by Board

Lists of parts for various boards including DISC TABLE, DISPLAY, DSP, FUNC, HEADPHONE, LOADING MOTOR.

Miscellaneous Components and Manuals

Miscellaneous Parts and Hardware

Lists miscellaneous components, hardware, and packing materials.

Service Manual Supplement

Supplement 1 - US Model Side Panel

Supplement regarding US model side panel disuse.