Section 12
ILLUSTRATIONS AND PARTS LIST
85
12.4 MOTOR, COMPRESSOR, FRAME AND PARTS WITH SPIRAL VALVE
key part
number description number quantity
1 motor, 100hp univ/50/60 (I) -1
2 compressor, unit dxr204220 (II) -1
3 guard, cplg 02250050-131 2
4 adapter, air inl ls20 dir drv 02250065-044 1
5 adapter, motor 02250069-127 1
6 flange, kit sae splt 2.5” - viton 02250099-416 1
7 flange, kit sae splt 3” - viton 02250100-926 1
8 frame, base ls20-100 02250127-524 1
9 adapter, discharge 3” 02250127-557 1
10 support, motor 02250127-740 1
11 support, compr front 02250127-741 1
12 support, compr rear 02250127-742 1
13 support, compr rear foot 02250127-748 1
14 joint, expansion ls20-100 spvlv 02250127-907 1
15 hub, coupling rex viva 2-1/8” 02250129-705 1
16 element, coupling viva 245 (III) 02250129-707 1
17 hub, coupling rex viva 70mm 02250129-759 1
18 gasket, 8-1/2” x 10-1/2” x 1/32” 040422 1
19 isolator, vibration compr. - dxr20 250042-541 3
20 isolator, vibration 670-7 250042-756 2
21 nut, hex pltd 5/8-11 825210-559 1
22 nut, hex f pltd 3/8-16 825306-347 10
23 o-ring, viton 3 1/4 x 1/8” 826502-236 1
24 capscr, hex gr8 3/8-16 x 3/4 827906-075 10
(Continued on page 87)
(I) Motor may vary. Consult factory with machine serial number.
(II) There is an exchange program whereby a remanufactured compressor unit can be obtained
from Sullair distributors or the factory at less cost than the owner could repair the unit. For
information regarding the unit exchange program, contact your nearest Sullair representative
or the Sullair Corporation. For shaft seal repairs, refer to Section 12.2, Recommended Spare
Parts List.
The shaft seal is not considered part of the compressor unit in regard to the two year warranty.
The normal Sullair parts warranty applies. For shaft seal repairs order repair kit no. 02250045-161.
(III) For maintenance on drive coupling element, order replacement element no. 022500129-707.
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE THE SERIAL NUMBER OF COMPRESSOR
To Next Page
Loading...
Need help?
General
