Torqeedo Deep Blue - Component Selection Screen

60
DeutschEnglish
8. Troubleshooting
Lubrication valve Intervals
Lubrication points Lubricant to use When navigating
in freshwater
When navigating
in saltwater
Gearbox API GL-5
SAE 80 W 90
MIL-L 2105 C
(600 cc / 500 g)
Check lubrication after 10 operating hours. After that,
check every 50 operating hours. If necessary, apply
lubricant up to the calibration mark.
Propeller shaft Water repellent
marine lubricants
60 days 30 days
Clamping screws Water repellent
marine lubricants
60 days 30 days
Error Check / Remedy
Display does not react
after turning of key
switch or connection of
charging plug.
• Checkemergencyswitchforcorrectseatandtitifnecessary.
• Checkboat‘smainswitchandswitchonifnecessary.
• Check12Vbatterychargestatus.Incaseoflowchargelevelshutoffanydevices
which are not part of the propulsion system; avoid tilt use, charge with the help
ofexternalchargerifnecessary.Forreliableoperation,thesystemcontinuously
needs at least 11 V battery voltage
• Checkfuseofthe12Vbatterycircuitandreplacedefectivefuseifnecessary.
• Onlywhencharging:Checkelectricalconnectionsonland,i.e.sockets,cablesand
fuses, remedy
possible disorders.
Trim/tiltmotordoesn‘t
react when actuated
• Checkemergencyswitchforcorrectseatandtitifnecessary.
• Checkboat‘smainswitchandswitchonifnecessary.
• Checktiltoverloadswitch.Theswitchislocatedontheconnectionbox;youwill
identify it by the grey rubber cap. Remove rubber cap and press the switch be-
neath.(Overloadswitchtriggerswhentilt/trimmotorisactuatedforalongertime
although motor has already been trimmed until end stop.)
Trim/tilt motor audibly
works,butdoesn‘t
move
• Checkwhethermotorisalreadyatendstop.
• Checkwhethertiltlockonthetransombracketblockstiltmechanism.
Loosen if necessary.
• Checktrim/tiltmechanismforblockadeandremoveblockadeifnecessary.
Temperature warning
orunexpectedpower
reduction
• Tilttheenginefromthewaterandshutoffthesystem.Checkwhetherpropelleror
cooling water inlet is blocked by foreign objects. Clear blockade if necessary.
• Rinsecoolingconduit.
Failuretoexecuteordocumentrequiredserviceswillleadto
lossofwarranty.Pleaseensurethatallservicesareexecutedand
documented in your DEEP BLUE service book.