4 CLCH-SVX009J-EN
Table of Contents
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Overview of Manual . . . . . . . . . . . . . . . . . . . 5
Nameplate . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
General Information . . . . . . . . . . . . . . . . . . . . . 6
Operating Environment . . . . . . . . . . . . . . . . 6
Unit Description . . . . . . . . . . . . . . . . . . . . . . . 6
Control Solutions . . . . . . . . . . . . . . . . . . . . . . 7
Model Number Descriptions . . . . . . . . . . . . . . 8
Pre-Installation . . . . . . . . . . . . . . . . . . . . . . . . . 11
Receiving and Handling . . . . . . . . . . . . . . . 11
Jobsite Storage . . . . . . . . . . . . . . . . . . . . . . 11
Site Preparation . . . . . . . . . . . . . . . . . . . . . . 12
Roof Curb Installation Checklist . . . . . . . . . 13
Dimensions and Weights . . . . . . . . . . . . . . . . 14
Service Clearances . . . . . . . . . . . . . . . . . . . . 14
Fans . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Motors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Installation - Mechanical . . . . . . . . . . . . . . . . 20
Lifting and Rigging . . . . . . . . . . . . . . . . . . . 20
Unit Placement and Assembly for Indoor Air
Handlers
. . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Unit Placement and Assembly for Outdoor Air
Handlers
. . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Duct Connections . . . . . . . . . . . . . . . . . . . . . 35
Field Conversions . . . . . . . . . . . . . . . . . . . . 36
Coil Piping and Connections . . . . . . . . . . . . . 38
General Recommendations . . . . . . . . . . . . 38
Drain Pan Trapping . . . . . . . . . . . . . . . . . . . 38
Steam Coil Piping . . . . . . . . . . . . . . . . . . . . 39
Suction Lines . . . . . . . . . . . . . . . . . . . . . . . . 44
Expansion Valves . . . . . . . . . . . . . . . . . . . . . 44
Hot Gas Bypass . . . . . . . . . . . . . . . . . . . . . . 44
Remodel, Retrofit, or Replacement . . . . . . 45
Field-Installed Evaporator Piping Examples .
46
Electrical Requirements . . . . . . . . . . . . . . . . . 51
Start-Up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Pre-Startup Checklist . . . . . . . . . . . . . . . . . . 59
Unit Operation . . . . . . . . . . . . . . . . . . . . . . . .60
External Insulating Requirements . . . . . . . .64
Routine Maintenance . . . . . . . . . . . . . . . . . . . .65
Maintenance Checklist . . . . . . . . . . . . . . . . .65
Air Filters . . . . . . . . . . . . . . . . . . . . . . . . . . . . .66
Coils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .66
Drain Pans . . . . . . . . . . . . . . . . . . . . . . . . . . . .69
Low Limit Switch . . . . . . . . . . . . . . . . . . . . . .69
Fans . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .72
Outside Air Intake Hoods . . . . . . . . . . . . . . .73
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . .74