PERIODIC SERVICES
Period 1 month 3 months 6 months 9 months 12 months 15 months 18 months 21 months 24 months
Km 500 - 2500- 5000- 8500- 11500- 14500- 17500- 20500- 23500-
ITEM 750 3000 6000 9000 12000 15000 18000 21000 24000
Front fork oil – – – – – – – – R
Both wheel free rotation / noise I I I I I & L I I I I & L
Front and rear suspension I I I I I I I I I
All fasteners I & TI – I & TI – I & TI – I & TI – I & TI
All bulbs, horn and switches working I I I I I I I I I
Head lamp beam I & A I & A I & A I & A I & A I & A I & A I & A I & A
Battery electrolyte level I & T I & T I & T I & T I & T I & T I & T I & T I & T
Specific gravity & voltage6 I I I I I I I I I
Brake light / self start switch I I I I I I I I I
Brakes free play I & A I & A I & A I & A I & A I & A I & A I & A I & A
Brake shoe wear – – I – I – I – R
Tyre pressure at cold condition I & S I & S I & S I & S I & S I & S I & S I & S I & S
Idling speed7 I & A I & A I & A I & A I & A I & A I & A I & A I & A
PERIODIC MAINTENANCE SCHEDULE (months or km whichever occurs earlier)
The above maintenance schedule is given for the warranty period. In the post warranty period it is recommended that maintenance services are
done in similar intervals for good performance of your vehicle.
R - Replace; I - Inspect; T - Top up; C - Clean; A - Adjust; D - Decarbonise; VL - Valve lapping; TU - Tune; L - Lubricate; TI - Tighten; S - Set; DR - Drain oil
1 2 3
Drain oil from collection tubes if necessary Tune carburettor if necessary Replace if necessary
4 5 6
Clean the cover with air & Lubricate kick starter with grease Adjust if required Recharge if necessary
7
Idling CO% should be set with the help of exhaust gas analyser and tachometer only
MAINTENANCE
MAINTENANCE
33
To Next Page
Loading...
Need help?
General
