PREOPERAPREOPERATIONAL TIONAL CHECKSCHECKS
4-84-8
2222
MAST MAST LOCKING LOCKING BOLTBOLT
Check the mast locking bolt for looseness or missing.Check the mast locking bolt for looseness or missing.
2323
LIFT LIFT CHAIN CHAIN TENSIONTENSION
WARNINGWARNING
Make sure the tension is the same on each chainMake sure the tension is the same on each chain
of the chain set; otherwise, uneven load willof the chain set; otherwise, uneven load will
occur so that the truck might tip over. A possibleoccur so that the truck might tip over. A possible
shock load might break the chains.shock load might break the chains.
Raise the forks about 5 cm off the ground or floorRaise the forks about 5 cm off the ground or floor
surface and check that the tension will be the same onsurface and check that the tension will be the same on
each chain of the chain set.each chain of the chain set.
If the tension is not equal, adjust it with the chain anchorIf the tension is not equal, adjust it with the chain anchor
bolt.bolt.
AfteAfter r adjuadjustmenstment, t, secusecurely rely tightighten ten the the lock lock nut nut of of thethe
chain anchor bolt.chain anchor bolt.
22
2 2 : : LIFT LIFT CHAINCHAIN
33
3
3 : : BATTERY BATTERY HOOKHOOK
11
1 1 : : MAST MAST LOCKING LOCKING BOLTBOLT
After completing the checks fromAfter completing the checks from
11
throughthrough
2323
, proceed to battery checks. Turn the, proceed to battery checks. Turn the
key switch “ON” and pull out the battery unit from the truck referring to page 3-14.key switch “ON” and pull out the battery unit from the truck referring to page 3-14.
After pulling out the After pulling out the battery unit, turn the key battery unit, turn the key switch “OFF” and disconnect the batteryswitch “OFF” and disconnect the battery
connectors.connectors.
2424
BATTERBATTERY Y HOOKHOOK
Check that the battery hook is not damaged or missing.Check that the battery hook is not damaged or missing.
To Next Page
Loading...
