UniCarriers FRSB14-8 - Inspection and Service

INSPECTION AND SERVICEINSPECTION AND SERVICE
1-281-28
 DANGERDANGER
■■ Inspection and maintenance must onlyInspection and maintenance must only
be performed by qualied be performed by qualied personnelpersonnel
Inspection and maintenance of the truckInspection and maintenance of the truck
should be performed only by qualified andshould be performed only by qualified and
authorized personnel. Improper inspection,authorized personnel. Improper inspection,
maintenance or repairs will cause damage tomaintenance or repairs will cause damage to
the truck or a serious accident.the truck or a serious accident.
■■ Precautions to take when usingPrecautions to take when using
battery chargersbattery chargers
•• Do not disconnect the power supply plugDo not disconnect the power supply plug
or battery connectors during charging;or battery connectors during charging;
otherwise there is a danger of generatingotherwise there is a danger of generating
sparks and causing an explosion.sparks and causing an explosion.
•• Do not try to touch any components insideDo not try to touch any components inside
the charger.the charger.
■■ Precautions to take when using a jackPrecautions to take when using a jack
Do not go under the truck while it is jacked up.Do not go under the truck while it is jacked up.
The truck might fall, crushing you under it.The truck might fall, crushing you under it.
Before jacking up the truck:Before jacking up the truck:
••
 Remove the load from the truck.Remove the load from the truck.
•• Block the wheels to prevent an accidentalBlock the wheels to prevent an accidental
roll.roll.
•• The operator must leave the operator’s seat.The operator must leave the operator’s seat.
 Lift the Lift the truck off truck off the ground the ground a a little bit little bit andand
put supports under the frame at both sidesput supports under the frame at both sides
of the truck to prevent the truck from falling.of the truck to prevent the truck from falling.

WARNINGWARNING

■■
Do not operate a truck if it is need of repairDo not operate a truck if it is need of repair
If at any time your lift truck is found to be in need ofIf at any time your lift truck is found to be in need of
repair, or is defective or unsafe, hang a sign in therepair, or is defective or unsafe, hang a sign in the
control area that says DO NOT OPERATE, removecontrol area that says DO NOT OPERATE, remove
the key and then report the problem to the designatedthe key and then report the problem to the designated
supervisor. The truck should be taken out of servicesupervisor. The truck should be taken out of service
until it has been restored to a safe operating condition.until it has been restored to a safe operating condition.
■■ Park on hard, level groundPark on hard, level ground
Before performing inspection and maintenance,Before performing inspection and maintenance,
make sure to park the truck on a hard, level surface.make sure to park the truck on a hard, level surface.
Also make sure the place is Also make sure the place is dry and dust-free.dry and dust-free.
■■ Insure good ventilationInsure good ventilation
When performing inspection and maintenanceWhen performing inspection and maintenance
indoors, make sure there is good ventilation.indoors, make sure there is good ventilation.
■■ Have re prevention equipment handyHave re prevention equipment handy
Have re prevention equipment handy wheneverHave re prevention equipment handy whenever
working indoors. Know how to use it.working indoors. Know how to use it.
■■Wipe up any spilt oil or greaseWipe up any spilt oil or grease
Wipe up any spilt oil or grease. If the truck isWipe up any spilt oil or grease. If the truck is
contaminated with oil or grease, it is difficult forcontaminated with oil or grease, it is difficult for
you to nd possible cracks or other defects.you to nd possible cracks or other defects.
■■ No re allowed (when handlingNo re allowed (when handling
lubricants, batteries, cloth wetted withlubricants, batteries, cloth wetted with
oil)oil)
No re is allowed. Never smoke or use re or aNo re is allowed. Never smoke or use re or a
naked ame when handling lubricants, batteries ornaked ame when handling lubricants, batteries or
cloth with oil on it.cloth with oil on it.
■■ Use the appropriate toolsUse the appropriate tools
Use appropriate tools, suitable for the job youUse appropriate tools, suitable for the job you
have been assigned. Using inappropriate toolshave been assigned. Using inappropriate tools
might cause a serious accident.might cause a serious accident.
■■ Do not use tools Do not use tools for other purposesfor other purposes
than those speciedthan those specied
Do not use tools for purposes other than theDo not use tools for purposes other than the
specied ones. You can cause a serious accident.specied ones. You can cause a serious accident.
■■ Avoid loose tting clothingAvoid loose tting clothing
Wear the protective clothing called for by the jobWear the protective clothing called for by the job
conditions.conditions.
■■ Wear safety gear (hard hat, safetyWear safety gear (hard hat, safety
shoes, safety glasses, gloves)shoes, safety glasses, gloves)

https://www.forkliftpdfmanuals.com/