3-13-1
A variety of A variety of safety instructions safety instructions are found are found throughoutthroughout
this manual. Follow all the instructions, for the safethis manual. Follow all the instructions, for the safe
operation and servicing of the truck.operation and servicing of the truck.
Safety instructions are accompanied by the safetySafety instructions are accompanied by the safety
alert symbols and signal words shown below.alert symbols and signal words shown below.
This is the safety alert symbol. It is used to warn theThis is the safety alert symbol. It is used to warn the
reader about a potential source of human injury. Toreader about a potential source of human injury. To
prevent injury or death, make sure you understandprevent injury or death, make sure you understand
and follow all the safety messages following this safetyand follow all the safety messages following this safety
alert symbol.alert symbol.
Signal wordSignal word
(designates the(designates the
degree of hazard)degree of hazard)
DenitionDenition
DANGERDANGER
Indicates an imminently hazardousIndicates an imminently hazardous
situation which, if not avoided, willsituation which, if not avoided, will
result in death or result in death or serious injury.serious injury.
WARNINGWARNING
In dica tes a potentiall y hazardousIndic ates a po ten tia l ly hazardous
situation which, if not avoided, couldsituation which, if not avoided, could
result in death or result in death or serious injury.serious injury.
CAUTIONCAUTION
In dica tes a potentiall y hazardousIndic ates a po ten tia l ly hazardous
situation which, if not avoided, maysituation which, if not avoided, may
result in minor or moderate result in minor or moderate injuryinjury..
CAUTION CAUTION
Indicates a hazardous situation which,Indicates a hazardous situation which,
if not avoided, may result in damage toif not avoided, may result in damage to
the truck or other the truck or other propertyproperty..
NOTENOTE
Indicates information which will helpIndicates information which will help
extend the service life of the truck.extend the service life of the truck.
3. OPERATION3. OPERATION
CONTENTSCONTENTS
PROPER OPERATION .......................................3-2PROPER OPERATION .......................................3-2
DURING DURING BREAK-IN BREAK-IN .............................................................................. 3-23-2
RELATIONSHIP RELATIONSHIP BETWEEN BETWEEN THE THE STABILITYSTABILITY
OF THE TRUCK AND LOAD OF THE TRUCK AND LOAD .................................................... 3-23-2
BASIC BASIC LOAD LOAD CENTER CENTER AND AND RARATED TED LOAD LOAD .... 3-33-3
THE THE STSTABILITY ABILITY OF OF LIFT LIFT TRUCK TRUCK .................................... 3-33-3
TRANSPORTING TRANSPORTING THE THE LIFT LIFT TRUCK TRUCK .......................... 3-43-4
MOVING MOVING THE THE LIFT LIFT TRUCKTRUCK
(IN AN EMERGENCY) (IN AN EMERGENCY) ........................................................................ 3-53-5
OPERAOPERATING TING THE THE LIFT LIFT TRUCK TRUCK .......................................... 3-63-6
LOAD HANDLING ...............................................3-8LOAD HANDLING ...............................................3-8
PICK-UP PICK-UP ..................................................................................................................3-83-8
STACKING STACKING......................................................3-8......................................................3-8
UNSTUNSTACKING ACKING ................................................................................................ 3-93-9
BATTERY CARE ...............................................3-10BATTERY CARE ...............................................3-10
BABATTERY TTERY ELECTROLELECTROLYTE YTE LEVEL LEVEL .............................. 3-103-10
BATTERY BATTERY ELECTROELECTROLYTE LYTE SPECIFSPECIFICIC
GRAVITY ......................................................3-12GRAVITY ......................................................3-12
CHARGING CHARGING THE THE BABATTERY TTERY .................................................. 3-133-13
REMOVING REMOVING AND AND REINSTREINSTALLINGALLING
THE BATTERY ............................................3-14THE BATTERY ............................................3-14
STSTAATIONARY TIONARY BABATTERY TTERY CHARGER ................CHARGER ................3-153-15
STASTATIONARY TIONARY BATTERY BATTERY CHARGERCHARGER
(OPTION) .....................................................3-15(OPTION) .....................................................3-15
POWER POWER SUPPLY SUPPLY EQUIPMENEQUIPMENTT
FOR BATTERY CHARGER FOR BATTERY CHARGER .................................................... 3-203-20
STORING ..........................................................3-21STORING ..........................................................3-21
BEFORE BEFORE STORING STORING ............................................................................ 3-213-21
DAILDAILY Y STORAGE STORAGE .................................................................................. 3-213-21
LONG-TERM LONG-TERM STORAGESTORAGE..............................3-21..............................3-21
OPERAOPERATING TING AFTER AFTER LONG-TERMLONG-TERM
STORAGE STORAGE ........................................................................................................ 3-213-21
To Next Page
Loading...
