To Next PageTo Next PageWhy won't my Weber Summit PLATINUM D4 burners light?
The excess flow safety device might have activated. To reset it, turn all burner control knobs and the cylinder valve OFF. Disconnect the regulator from the cylinder. Turn burner control knobs to HIGH and wait at least 1 minute. Then, turn burner control knobs OFF, reconnect the regulator to the cylinder, and slowly turn the cylinder valve on. Refer to 'Lighting Instructions'.
What to do if my Weber Summit PLATINUM D4 Grill burner does not light?
Try relighting the burner by holding the burner control knob down, and continue holding it down until 20 seconds after the burner has ignited. When relighting, wait to see the entire ceramic surface become alight before counting 20 seconds. Also, replace the battery in the igniter button module and reseat the burner ring.
General| Number of Burners | 4 |
|---|---|
| Total Cooking Area | 624 sq. in. |
| Side Burner | Yes |
| Rotisserie Burner | Yes |
| Grates Material | Stainless Steel |
| Burner Material | Stainless Steel |
| Grate Material | Stainless Steel |
| Type | Gas |
| Fuel Type | Liquid Propane |
| Warranty | 10 years |
| BTU Side Burner | 12, 000 BTU |
| Primary Cooking Area | 468 sq. in. |
| Cooking Area | Primary: 468 sq. in., Secondary: 156 sq. in. |
Immediate steps if gas is smelled, including danger of fire/explosion.
Warnings about flammable liquids, storage, and operating conditions.
Specific safety advice for liquid propane gas units, including cylinder handling.
Details on warranty periods for various grill parts and conditions.
Instructions for storing the grill when not in use, focusing on cylinder safety and clear areas.
General advice, including preheating, grease management, and cleaning procedures for grill parts.
Introduction to direct and indirect grilling methods.
Procedures for filling, connecting, and handling liquid propane cylinders safely.
Steps to prepare for and perform gas leak checks before operation.
Detailed steps for connecting the LP cylinder to the grill regulator, emphasizing hand-tightening.
Instructions for removing the control panel to access internal components.
Step-by-step guide to check for gas leaks using a soap and water solution, with safety warnings.
Identification of specific connection points requiring leak checks, with actions for leaks.
Instructions for reinstalling the control panel, including connecting igniter wires.
Guidance on checking the LP tank's fuel level and safe refilling procedures.
Tips for safe handling, storage, and transport of liquid propane cylinders.
Requirements for LP cylinders, including DOT certification, size, and connection care.
Overview of direct cooking, preheating, and the Flavorizer system.
Detailed explanation of the direct cooking method for various foods.
Detailed explanation of the indirect cooking method for slower cooking foods.
Helpful advice for grilling, including preheating, flare-ups, and food handling.
Instructions for using the Crossover ignition system and troubleshooting.
Steps to safely turn off the grill burners and gas supply.
Instructions for lighting the grill manually using a match.
How to use the smoker with wood chips and clean the smoker unit.
Procedure for turning off the smoker burner and gas supply.
Steps for manually lighting and then safely extinguishing the smoker burner.
Step-by-step guide to assemble the rotisserie motor, shaft, and forks.
Important safety precautions and setup steps before using the rotisserie.
Instructions for operating the rotisserie motor and cooking food.
Safety warnings and initial steps for lighting the rotisserie burner.
Steps for manually lighting and then safely extinguishing the rotisserie burner.
Final steps for safely extinguishing the rotisserie burner after use.
Common problems with main and smoker burners, their checks, and cures.
Common problems with the rotisserie burner, including failure to light or low flame.
Inspecting and cleaning burner screens to prevent blockages.
Procedures for cleaning main burners and understanding the correct flame pattern.
Recommendations for annual inspection and cleaning of the grill components.
Step-by-step guide for replacing the main burners of the grill.
Instructions for safely removing the manifold assembly from the grill.
Steps for disassembling and reassembling burner tubes and the crossover tube.
Troubleshooting and maintenance for the crossover ignition system.
Guide on how to replace the batteries for the igniter button.
