Weil-McLain PLUS LINE PLUS-E017-A/1206 - PLUS LINE Indirect-Fired Water Heaters - Series; GOLD Plus 30;40;60;80 or PLUS 40;60;80

68 pages

Save Page as PDF

To Next Page

To Previous Page

Part Number PLUS-E017-A/1206

PLUS LINE

Indirect-Fired Water Heaters – Series 3

GOLD Plus 30/40/60/80 or

PLUS 40/60/80

Series 3

E Replacement parts continued

Main Page

Default Chapter2
- Hazard Definitions2
- Hot Water Can Scald2
- Table of Contents3
- Zoning with Zone Valves4
G Eneral Installation ( All Water Heaters )6
A1. Pre-Installation6
- Codes6
- Location6
- Recommended Clearances6
- Operating Restrictions7
- Code Restrictions7
A2. Water Heater Piping8
- Temperature & Pressure Relief Valve8
- Air Vent8
- Piping Drawings and Drain Valve Information9
- Thermal Expansion13
- Water Hammer13
- General Piping Information13
- Domestic Water Piping14
- Boiler Water14
A3. Water Heater Wiring15
- Water Heater Thermostat Connection15
A4. Water Heater Start-Up16
- Filling the Inner (Domestic Water) Tank16
- Filling the Outer (Boiler Water) Tank16
- Start-Up Checklist17
A5. Adjusting Water Heater Temperature18
- Safety Warning and General Notes18
- Setting the Thermostat - GOLD Plus 30/40/60/80 or Plus 40/60/8019
- Setting the Thermostat PLUS 100/110/11919
A6. Water Heater Maintenance20
- Maintenance Schedule - Annual Service by Qualified Technician20
- Maintenance Schedule - Homeowner's Monthly Maintenance20
- Filling21
- Draining21
- Draining Inner (Domestic Water) Tank21
- Draining Outer (Boiler Water) Tank21
A7. Recirculation and Heat Tracing22
- Maintaining Domestic Water Temperature in the Supply Piping22
- Time Delay at Fixtures22
- Balancing22
- Components Required22
- Connecting to the Water Heater22
Gas24
B1. Install System Water Piping25
Install System Water Piping25
- System Water Piping Methods25
- Boiler Circulator25
- Sizing Space Heating System Piping25
- Zoning with Zone Valves26
- Zoning with Circulators27
B2. Install Boiler-To-Water Heater Piping28
- Combined Space Heating/Water Heating Applications28
- Dedicated Water Heating-Only Applications28
B3. Field Wiring - Gas-Fired Boilers Only30
B3. Field Wiring30
- Installation Must Comply with30
- Line Voltage Connections30
- Wiring Boiler Circulator30
- Wiring Water Heater Circulator30
- Wiring PLUS Circulator30
- Wiring a System Circulator31
- Routing Line Voltage Wiring31
- Low Voltage Connections31
- Room Thermostat (Space Heating)31
- Outdoor Temperature Sensor31
- Water Heater Thermostat31
- Additional Limits31
- PLUS Water Heater Thermostat31
B4. Start-Up - Gas-Fired Boilers Only33
B4. Start-Up - Gas-Fired Boilers Only33
- Follow Boiler Manual33
- Set Space Heating Operation33
- Water Heater Operation33
- Water Heater Operation Setup33
- Verify Space Heating Operation33
- Verify Water Heater Operation34
- Operating Information34
- Replace Boiler Jacket Front Door34
C. Boiler Piping (Except35
- Boiler-Side Piping35
Zoning With Pumps35
- Multiple Water Heater Applications35
- Wiring Options36
- Two-Pipe System Piping - Figure 2036
- Primary/Secondary Piping - Figure 2137
- Primary/Secondary Piping - Figure 2238
- Figure 2440
- Gas )35
- GOLD Plus 30/40/60/80 or Plus 40/60/8036
- GOLD Plus 30/40/60/80 or Plus 40/60/8040
Dedicated Boiler Applications40
- Applications41
- Figure 2541
Steam Boiler Applications44
- Connecting Water Heater to Steam Boiler44
- Installation and Start-Up of Water Heaters Connected to Steam Boilers44
- Special Considerations44
- Iring Requirements47
- Wiring Requirements - Circulators47
- Wiring Requirements - Zone Valves47
- Boiler Models Requiring Domestic Priority with GOLD Plus 3047
- Zoning with Weil-Mclain Circulator Zone Controller (WMCR)48
Zoning with Pumps48
- Oning with Pumps48
- Weil-Mclain Circulator Zone Controller48
- Other Options for for Zoning with Pumps49
- Plus 100/110/11964
  - Plus 100/110/11965
F. Water Heater Dimensions&Performance Ratings66
- Water Heater Dimensions66
- Performance Ratings67
- Warranty68

Weil-McLain PLUS LINE PLUS-E017-A/1206 - PLUS LINE Indirect-Fired Water Heaters - Series; GOLD Plus 30;40;60;80 or PLUS 40;60;80

Table of Contents

Related product manuals