MAINTENANCE INTERVALS
3-3
30 * Front fork leg(s)
• Clean.
• Inspect and adjust.
• Replace oil.
• Replace oil seal.
• Clean and grease oil seals and
dust seals.
31 Protector guide • Replace.
32 * Rear shock absorber
• Inspect and adjust.
• Grease pillow balls and bearings.
(After rain ride)
• Check for tightening torques.
33 *Brake(s)
• Adjust lever position and pedal
height.
• Lubricate pivot point.
• Check brake disc surface.
• Check fluid level and leakage.
• Retighten brake disc bolts, caliper
bolts, master cylinder bolts and
union bolts.
(Check for tightening torques.)
• Replace pads.
• Replace brake fluid. Every one year
34 * Swingarm • Inspect, lube and retighten.
35 *
Relay arm, connect-
ing rod
• Inspect, lube and retighten.
36 * Steering head
• Inspect free play and retighten.
(Check for tightening torques.)
• Clean and lube.
(After rain ride)
• Replace bearings.
37 * Tire, wheels
• Inspect air pressure, wheel run-
out, tire wear and spoke loose-
ness.
• Retighten sprocket bolt.
• Check the bearing.
• Replace
bearings.
• Lubricate.
38 * Drive chain
• Clean, lubricate, slack, alignment.
• Replace.
39 * Drive chain guide • Inspect wear.
40 *
Drive chain guide and
drive chain support
• Replace.
41 Cables
• Routing (Connection)
• Check and grease.
• Check throttle cables on the throt-
tle body for dirt and wear.
42 Levers • Adjust clutch lever free play.
No. Item Routine
After
break-in
Every
race
(about 2.5
hours)
Every
third race
(about 7.5
hours)
Every
fifth race
(about 12.5
hours)
As
required
To Next Page
Loading...
