AMSAFE SEATBELT AIRBAG SYSTEM
INSTALLATION, HANDLING AND SHIPPING INSTRUCTIONS E510629
01-Aug-2013
Page ii
Revision History
Rev. Prepared Approved Revision Summary Date
– F. Armenta W. Gehret Initial Issue 10-Feb-2009
A F. Armenta J. Magish Page 1003 – updated page 1003 SDT Diagnostic
Check procedures table.
Pages 4003-4005 – Removed recommendation
that the EMA is disconnected for shipment of
seats. Added statement to prevent buckle from
being in proximity of the switch.
17-Mar-2009
B F. Armenta J. Magish Updated EMA and Inflator pics;
Page 1003 – added warning to disconnect SDT
after diagnostic check in order to prevent EMA
battery from draining.
11-Nov-2009
C F. Armenta J. Magish Updated nomenclature: Inflatable Lap Belt Assy
was Seatbelt Airbag Assembly (SAA);
Page 3002 – added EMA torque values to Table
06-Apr-2010
D. F. Armenta D. Potter Updated nomenclature: AmSafe Airbag System
(AmSafe Airbag) now AmSafe Seatbelt Airbag.
Updated Packing and Shipping Requirements for
Inflators: removed statement to use cargo only
when shipping; added EX numbers for Autoliv
Inflators
07-May-2010
E F. Armenta J. Magish Revision History – removed “Added Section
2000, Inspection/Check.” This section was never
added.
Page 4007 – Updated Packing and Shipping
Requirements for Inflators: removed statement to
use cargo only when shipping
30-Jun-2010
F L. Langston J. Magish Reformatted document; added instruction for
systems with no activation switch throughout
document; removed warnings/cautions with
instruction to avoid magnetic fields in vicinity of
EMA as this is no longer a valid issue; added
MSDS, EX numbers, and weights for ROI
inflators.
31-Aug-2010
G F. Armenta J. Magish Added Figure 3 – dual inflator system;
referenced dual inflator system throughout
document where inflator is referenced. Updated
Figure 11 to show locked and unlocked
connector position. AmSafe logo updated;
nomenclature: AmSafe was AmSafe Aviation.
14-Apr-2011
H F. Armenta J. Magish Updated to reference a structure mounted
system; added Figure 4 – Representative
Structure Mounted System; added Figures 14 &
15 for detail on expiration date of Inflator and
EMA; updated caution statement for mishandling
of EMA.
11-Mar-2011
To Next Page
Loading...