55
Division II - Operation/
Maintenance
Previous Main TOC Section TOC Next
I = Inspect and clean, adjust, lubricate, replace as necessary * = Dealer maintenance
T = Tighten R = Replace C = Clean
Maintenance Schedule
Item Page
Initial
100
miles
Every
100
miles
Every
300
miles
Every
500
miles
Every
1250
miles
Every
5000
miles
Battery 61 I I I
* Engine nuts and bolts — I I
* Valve clearance — I
Transmission lubricant 58 I I I
58 Replace every 4 years
Liquid cooling system
56 I
Inspect every time before
riding
Replace coolant
every 2 years
Fuel filter 64 I I R
Oil filter 57 Change after initial 300 miles R
Throttle cable 65 I Inspect every time before riding
Fuel/vent hoses 48 I Inspect every time before riding
48 Replace every 2 years
Engine oil 57 Change after initial 300 miles R
Air filter 65 I I R
Gear lubricant (Front differential -
rear drive)
58 I I
58 Replace every 4 years
V-Belt 66 I I
Muffler/spark arrester 67 C
Tires/air pressure 67 I Inspect every time before riding
32 I Inspect every time before riding
* Brake components 59 I Inspect every time before riding
Brake fluid 59 I *Replace every 2 years
Brake hoses 60 I *Replace every 4 years
* Steering — I Inspect every time before riding
* Suspension (Ball joint boots,
drive axle boots front and rear, tie
rods, differential and rear drive
bellows)
— I Inspect every time before riding
* Chassis nuts and bolts — I T
Frame/welds/racks — I I
Electrical connections — I I
Headlight/taillight-brakelight 68 I Inspect every time before riding
Fuel injection —
I
Timing belt — Replace every 5,000 miles
Alternator belt — I
I
Engine oil level 48 I Inspect every time before riding
Coolant level 56 I Inspect every time before riding
To Next Page
