69
Wiring diagram rear
1604 7781 02-2
Note 1:
Connector: Deutsch HD N 36 - 24-19 SN - 059
Terminals: Size 12 (large): Deutsch 0462-203-12141
Size 16 (small): Deutsch 0462-201-16141
Unused Cavities to be sealed with: Deutsch 114017
Note 2:
Connector: Deutsch DTM 06-2S
Terminals: Deutsch 1062-20-0122
Secondary Lock: Deutsch WM 2S
Note 3:
Connector: Deutsch DT 06-2S
Terminals: Deutsch 0460-201-16141
Secondary Lock: Deutsch W 2S
Note 4:
Connector: Deutsch HD N 34 - 24-19 - PN - 059
Terminals: Size 12 (large): Deutsch 0460-204-12141
Size 16 (small): Deutsch 0460-202-16141
Nut: Deutsch 112263-90
Lockwasher:Deutsch 112264
Unused Cavities to be sealed with: Deutsch 114017
Note 5:
Connector: Deutsch HD N 34 - 18-8 PN - 059
Terminals: Deutsch 0460-204-12141
Unused Cavities to be sealed with: Deutsch 114017
Note 6:
Connector: AMP 0-963040-3
Terminals: AMP 0-929939-1
Wire seal: AMP 828904-1
Seal Grommet: Bosch 1280 703 26026
Note 7:
- Terminals 84, 85 shall be equipped with a label with printing:
“ALWAYS INSULATE WIRE”.
- Label and printing must be water, oil and coolant resistant.
- Terminals 84, 85, 86 shall be equipped with a shrinkable sleeve
with a layer of glue, as in drawing below, and strapped to the
harness with nylon straps.
1: Wire
2: Sleeve
3: Squeezed tight when hot
Note 8:
Terminals 1 and 2 shall be equipped with rubber protection cap
AC nr: 1612 0846 00
Note 9:
Connector: Deutsch DTM 06-3S
Terminals: Deutsch 1062-20-0122
Secondary Lock:Deutsch WM 3S
Note 10:
Wire insulation should be resistant to oil, diesel fuel and coolant.
Note 11:
Connector according to DIN 72585 4 pins.
Connector: G&H 17984.000.001
Terminals: G&H 26570.201.184
Wire seal: G&H 14414.627.626
Unused cavities to be sealed with: G&H 14416.627.646
Strain relief of fuel level: G&H 14830.625.699
Wiring braided until connector, and attached to strain relief with
nylon strap.
Note 12:
Connector: Deutsch HD14-5-16P
Terminals: Deutsch 0460-202-16141
Unused Cavities to be sealed with: Deutsch 114017
Protective cover Deutsch HDC 16-5 fixed to harness with wire.
Both ends of wirde run at least 200mm into harness.
Blue119See note 12107
27 SEE NOTE 1 1000 1
ORANGE
ORANGE
49
50
SEE NOTE 1
SEE NOTE 1
24 SEE NOTE 1 1001 1
105
104
106
103
102
101
See Note 12
1.5 Red24M
28 1 ORANGE
SEE NOTE 12
Splice
Splice
1 Grey21
See Note 12
See Note 12
1 Grey20
1 Grey20
1 Grey21
48 SEE NOTE 1 28 1 ORANGE
25 SEE NOTE 1 28 1 ORANGE
99 SEE NOTE 11 28 1 ORANGE 100 Splice
98 See Note 6 AB1 1 BROWN 90 SEE NOTE 9
95 See Note 3 19 Blue1
94 9610 1
Orange
See note 3 See note 1
SPLICE
SEE NOTE 6
SEE NOTE 8
97
88
89 SEE NOTE 9 PE 1
YELLOW/GREEN
PE 2.5
YELLOW/GREEN
61 SEE NOTE 5
BROWN
BROWN
Blue419BSee note 786
51 Splice
1Red24M
1.5 Red24M
See Note 785
84 8724 4
Red
See note 7 See note 4
See Note 2
See Note 2
See Note 2
See Note 2
1 Orange4
See Note 182
Splice831 Orange4
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
178
79
39
40
62
82 1
Green
Purple
See note 6
See note 6
See note 4
See note 4
WIRE TERMINAL END BTERMINAL END A
TERMINALCOLORMM² NRNR
TERMINAL
NR
Orange4See Note 35
Blue1910
Blue
Blue
Blue
4
19B
19B
19B
See Note 1
See Note 2
56
76
8
Blue19See Note 36
Splice49Blue19See Note 24
See Note 430
38Orange5See Note 23 See Note 4
See Note 1136Purple83See Note 112
See Note 1135Green63See Note 111
58 See Note 1 19 Blue
21 See Note 1 19 Blue
Orange22See Note 147
Orange
See Note 123 Red4
1.5
4
1.5
Red24MSee Note 117
Red
Red
1.5
4
24
24
24
66
See Note 431Orange99
1.522See Note 122
Splice
Splice52Orange22See Note 27
See Note 157Red426See Note 126
Blue18See Note 146
Blue1829
Splice
Splice53Blue18See Note 120
See Note 4
33
Grey21See Note 119
See Note 432
Grey20See Note 118
See Note 434Green30
AMP 160136-0
28
64
44
See Note 5
See Note 4
See Note 443
67
68
41
77
42
57
77
Green
Purple
See note 6
See note 6
See note 4
See note 4
72
60
75
80
81
SEE NOTE 1
SEE NOTE 5
SEE NOTE 1
SEE NOTE 1
SEE NOTE 1
A1
A2
B1
B2
PE
1.5
1.5
2.5
2.5
2.5
BLACK
BROWN
BLACK
BLACK
YELLOW/GREEN
59
93
62
63
SEE NOTE 5
SEE NOTE 5
SEE NOTE 5
74
71
73
SEE NOTE 1
SEE NOTE 1
SEE NOTE 1
A11
A21
1.5
2.5
Blue1.519BSee note 565
123
10101010
To Next Page
Loading...
