BAC FXV - Page 10

WWW.BALTIMOREAIRCOIL.COM
8
Figure 7c. Lower Section Lift
W1
(MIN)
H
Safety
Slings
Spreader
Bar
Lifting Cable
Figure 7a. Plenum Module Lift
Plenum Module
Safety
Slings
W1
(MIN)
Spreader Bar
Lifting Cable
Safety
Slings
Coil Module
Spreader Bar
Lifting Cable
W1
(MIN)
Figure 8. Lower Section Sealing Detail
SpreaderBar
LiftingCable
Spreader
Bar
LiftingCable
Plenum Module
Coil Module
Safety
Slings
Safety
Slings
W1
(MIN)
W1
(MIN)
PerimeterFlange
Seals
PlenumStepSeal
NOTE: All single-cell and multi-cell
units must be rigged one section
at a time.
Dual Air Intake Four Piece Cell Assembly Instructions:
1. Removeanyaccessoriesshippedinthecoldwaterbasin.
2. Positionthelowersectionontheunitsupportsandboltinplace.
3. Wipemoistureanddirtfromtheperimeterangeandplenumstepasshownin
Figure 8.
4. Applyatbutylsealertape(BACpart#554000)tocriticalsealareasshownin
Figure 9.Applya2”x2”pieceofatbutylsealertapetothecornerriggingguidesas
showninFigure 10.Applyatbutylsealertapeacrosstheplenumstepasshownin
Figure 11.
5. Applyatbutylsealertapearoundtheentireperimeterofthelowersection.Align
thetapeontheperimeterangeasshowninFigure 12.SeeFigures 10and11for
criticalsealingareas.Allow1”overlaptapeattheselocations.
Figure 7b. Coil Module Lift