Camus Hydronics MFH060 - Default Chapter; Table of Contents

Table of Contents
1 GENERAL INFORMATION............................................................................................................1
2 BOILER LOCATION.......................................................................................................................2
3 PROVIDE AIR FOR COMBUSTION AND VENTILATION..............................................................3
4 ELECTRICAL WIRING...................................................................................................................4
5 MODULATION SEQUENCE ..........................................................................................................4
6 GAS SUPPLY AND PIPING...........................................................................................................5
7 VENTING.......................................................................................................................................6
7.1 OUTDOOR VENTING ...................................................................................................................8
7.2 SIDEWALL VENTING....................................................................................................................9
7.3 OUTDOOR AIR KIT.......................................................................................................................9
7.4 FILTER KIT ...................................................................................................................................9
7.5 STANDARD VENTING..................................................................................................................9
7.6 VENTING FOR CONDENSING APPLICATION...........................................................................10
8 ACCESSORIES...........................................................................................................................11
8.1 WATER FLOW SWITCH (shipped loose)....................................................................................11
8.2 LOW WATER CUTOFF (If Equipped)..........................................................................................11
8.3 RELIEF VALVE (shipped loose) ..................................................................................................11
9 FREEZE PROTECTION...............................................................................................................12
10 WARNING REGARDING CHILLED WATER SYSTEMS..............................................................12
11 PIPING OF BOILER TO SYSTEM ...............................................................................................13
12 PLACING BOILER IN OPERATION.............................................................................................14
13 IGNITION SYSTEM SAFETY SHUT-OFF DEVICE......................................................................14
14 LOW WATER TEMPERATURE SYSTEMS .................................................................................15
15 INSTANTANEOUS WATER HEATER..........................................................................................16
16 CONDENSING HEAT RECOVERY MODULE (CHRM)................................................................16
17 INSTRUMENTATION AND CONTROLS......................................................................................20
17.1 SAFETY CONTROLS..................................................................................................................20
17.2 CONTROL PANEL ......................................................................................................................20
17.3 SETTING THE APPLIANCE TEMPERATURE CONTROLLER ...................................................21
17.4 MODES OF OPERATION ...........................................................................................................21
18 MICOFLAME CONTROL PANEL.................................................................................................28
18.1 GENERAL SYMBOL DESCRIPTION ..........................................................................................29
18.2 MODE 1 & 2: SETPOINT OPERATION: VIEW DISPLAY............................................................30
18.3 MODE 1 & 2: SETPOINT OPERATION: ADJUST DISPLAY .......................................................31
18.4 MODE 3: DEDICATED DOMESTIC HOT WATER OPERATION: VIEW DISPLAY......................32
18.5 MODE 3: DEDICATED DOMESTIC HOT WATER OPERATION: ADJUST DISPLAY.................33
18.6 MODE 4 & 5: OUTDOOR RESET OPERATION: VIEW DISPLAY...............................................34
18.7 MODE 4 & 5: OUTDOOR RESET OPERATION: ADJUST DISPLAY ..........................................35
18.8 MODE 6 & 7: EXTERNAL TARGET TEMPERATURE INPUT OPERATION: VIEW DISPLAY.....36
18.9 MODE 6 & 7: EXTERNAL TARGET TEMPERATURE INPUT OPERATION: ADJUST DISPLAY 37
18.10 MODE 8: EXTERNAL DRIVE OPEATION: VIEW DISPLAY........................................................38
18.11 MODE 8: EXTERNAL DRIVE OPEATION: ADJUST DISPLAY ...................................................39
18.12 ERROR MESSAGES...................................................................................................................39
19 PILOT AND MAIN BURNER FLAMES .........................................................................................41
19.1 MAIN BURNER ...........................................................................................................................41
19.2 PILOT BURNER..........................................................................................................................44
20 OPERATION AND SERVICE.......................................................................................................44
20.1 PRE-START CHECKLIST ...........................................................................................................44
20.2 START-UP ..................................................................................................................................45