Caterham Seven - Service schedules - Duratec 310 only

52
Service schedules - Ford Sigma 125/140 & Duratec 175/180/210 Engine Variants
Service Interval
Annually or every 6,000
miles if sooner
Roadsport, Supersport, Supersport (R) and R400
New Car First
Service
First Annual
Second
Annual
For listed Sigma Engines and Duratec variants
3 Months
12 Months
24 Months
(or 1000)
(or 6000)
(or 12,000)
Engine oil
Check and top up (# check level before changing oil)

#
#
Engine oil
Drain and replace



Engine oil filter
Replace



Differential oil level
Check and top up



Gearbox oil level
Check and top up



Screen washer fluid level
Check and top up



Screen washers
Check operation and alignment



Brake fluid
Check level and top up



Coolant
Check level and top up



Coolant hoses
Check for condition, leaks and security



Alternator drive belt
Check tension and condition, replace if necessary



Roller Barrels
Check and set balance, idle and throttle pot settings



Lights and bulbs
Check all lights and replace bulbs as necessary



Switchgear
Check operation



Wheel nut torques
Check for tightness



Clutch
Check operation, adjustment & fluid level



Handbrake operation
Check and adjust



Brake pads
Check for wear, replace if necessary



CV gaitors
Check condition



Tyres
Check condition and pressure



Seatbelts and harnesses
Check for condition and operation



Horn
Check



Wipers
Check condition and operation, replace if necessary



Steering joints and gaitors
Check



Wheel bearing end float
Check and adjust



Brake hoses
Check condition and for leaks



Brake discs
Check for condition and wear



ECU diagnostics
Check if possible



Battery
Check security, condition and connections, top up



Headlight alignment
Check and adjust



Exhaust system
Check mountings and exhaust condition



Spark plugs
Replace



Suspension security
Check and retorque bolts



Suspension bushes
Check and replace if necessary



Front wheel alignment
Check and adjust if necessary



Brake pipes and unions
Check for security and leaks



Brake fluid
Replace



Clutch Fluid
Replace



Engine mountings
Check



Air filter
Clean, (change at 4 years)


4
Wheel bearings
Repack at 4 years


4
Brake hoses
Replace at 4 years


4
Coolant
Drain and replace at 4 years


4
Fuel lines
Check for security and leaks


4
Cam belts
Replace at 6 years or sooner if preferred (Sigma only)
6
Road test
To check dampers, brakes, steering, instruments etc.



4 - Items are required to be replaced every 4 years 6 - Items are required to be replaced every 6 years