CBE PC-540HY - Main Parts of the Electrical System; Control Panel PC-540 HY; Battery Charger A2018; Leisure Battery B2

MAINPARTSOFELECTRICALSYSTEM
GB
u
u
u
u
u
u
CONTROL PANEL “PC-540HY”-mains’ control,batterytest,tanktest,alarms.
RELAY BOX“DS-540HY”-relay,carbatteryrechargingdevice,protectionfuses.
12VDISTRIBUTIONBOX“DS-340HY”-batteryparallelingrelay(12V-70A),step’srelay,ampere-
meter.
BATTERY CHARGER“A2018”-buffer-systembatterycharger.
ELECTRONIC TANKPROBE-itmeasuresthecontentofthedrinkandwastewatertank,
visualizationin“%”.
STEMPROBE-itmeasuresthecontentofthesewagewatertank,threelevelsvisualization.
LEISUREBATTERY “B2”-itgivespowertoalltheusers.
CARBATTERY “B1”.
ENGINE ALTERNATOR-itrechargesinparallelboththecarandtheleisurebattery.
230VCUT-OUT board“DS-120HY”-itpowersandprotectsallthe230Vusers.
“50A”CAR(B1) ANDLEISURE(B2)BATTERY PROTECTIONFUSES.
u
u
u
u
u
ADVICEANDCHECKS
24
IMPORTANT
BATTERIES
BATTERYCHARGER
TANKPROBES
FUSES
w
w
Maintenanceinterventionsontheelectricimplantmaybecarriedoutbyspecializedpersonnel.
Beforecarryingoutmaintenancedisconnectthebatteryandthealimentationline.
Readwithcarethemaintenanceandinstructionsofuseofthebatteries.
Theacidkeptinthebatteriesispoisoningandcorrosive. Avoidanycontactwithskinandeyes.
Ifthebatteryiscompletelydischargeditneedsrechargingforalmost10hours.Ifdischargedformore
than8weeksitmaybedamaged.
Checkperiodicallytheleveloftheliquidofthebattery(withacid);theGEL batterydoesnotneedany
maintenancebutacontinuousrecharging.
Incaseofalongerstoptheservicesbatteryhastobeconnectedorrechargedregularly.
Replacethefusesafterfindingouttherealcauseofthedamageonly.
Incasethefusesarereplacedrespectthevalueoftheamperageestablished.
w
w
w
w
w
w
w
w
w
w
w
w
w
w
Checkthecorrecttighteningoftheconnectionbindingscrewandbrushofftheoxide.
Iftheleisurebatteryisremoved,isolatethepositivepole(inordertoavoidshort-circuitsduringan
accidentalcarenginestarting).
Checkthecorrectrecharging,lookingatthe2LEDsplacedonthefrontsideofthebatterycharger.
Thebatterychargercanbeconstantlyconnectedtothe230Vnet.
Thebatterychargermustbeinstalledinadryandventilatedplace.
Thebatterychargersuppliesnovoltageandcannotworkifnotconnectedtothebattery.
Neverletwaterinthetanksforlongtime,inordertoavoidfoiling,especiallyinthewastewatertank.
230VCUT-OUTBOX
w
w
w
w
w
Beforetakingawaythecover,checkifthe230Vsocketisdisconnected.
Inordertoavoiddamagestothebox,checkthecorrecttighteningoftheconnections.
Inordertocutpowertothewhole230Vsystem,pleasetakecarethatthe230Vmainswitchmustbe
onthe“0”(OFF)position.
Connectanddisconnecttheexternal230Vnetonlywhenthemainswitchisoff.
Incaseofautomaticswitchbreak,findthedamagebeforegivingpoweragaintotheelectricalsystem.