Cessna T188C - Page 51

MODEL
188 &
T188
SERIES
SERVICE
MANUAL
SPECIAL
INSPECTION
ITEMS
(Continued
from
page
2-28)
24. Fuel
quantity indicating
system operational
test is
required every
12 months. Refer
to Section
15 for
detailed
accomplishment
instructions.
25. At the
first 100-hour
inspection
on new,
rebuilt or overhauled
engines,
remove
and clean
the fuel injection
|
nozzles. Thereafter,
the
fuel injection nozzles
must be
cleaned at 300-hour
intervals
or more frequently
if
fuel stains are found.
2-54. COMPONENT
TIME
LIMITS
1. General
A. Most
components
listed
throughout
Section 2
should be inspected
as
detailed elsewhere
in
this section
and repaired,
overhauled
or replaced
as required.
Some components,
however,
have a time
or life
limit,
and must
be overhauled
or replaced
on or
before the
specified
time limit.
NOTE:
The terms
overhaul
and replacement
as used
within this section
are defined
as follows:
Overhaul - Item
may be overhauled
as defined in
FAR 43.2 or it can
be replaced.
Replacement
- Item
must be replaced
with a
new item or a
serviceable item
that is within
its service life
and
time limits or
has been
rebuilt as defined
in FAR
43.2.
B. This
section
provides a
list of items
which must
be overhauled
or replaced
at specific
time limits.
Table
1
lists those items
which Cessna
has mandated
must be overhauled
or replaced
at specific
time limits.
Table 2
lists component
time
limits which
have
been established
by
a supplier
to Cessna
for the
supplier's
product.
C.
In addition
to these
time limits,
the components
listed
herein are
also inspected
at regular
time intervals
set
forth in the Inspection
Charts,
and may
require overhaul/replacement
before the
time limit is
reached based
on service
usage and
inspection
results.
2. Cessna-Established
Replacement
Time Limits
A. The following
component
time limits
have been
established
by Cessna Aircraft
Company.
Table 1:
Cessna-Established
Replacement
Time Limits
COMPONENT
REPLACEMENT
TIME
OVERHAUL
Restraint
Assembly
Pilot Seat
Trim
Tab Actuator
Pitot and Static
System
Hoses
Engine Compartment
Flexible
Fluid-
Carrying
Teflon
Hoses
(Cessna-
Installed) Except
Drain Hoses
(Drain
hoses
are replaced
on condition)
Engine Compartment
Flexible
Fluid-
Carrying
Rubber
Hoses
(Cessna-
Installed)
Except Drain
Hoses
(Drain
hoses are
replaced
on condition)
1,000 hours
or 3
years,
whichever occurs first
10 years
10 years
or engine
overhaul,
whichever
occurs
first
(Note 1)
5
years or engine
overhaul,
whichever
occurs first
(Note
1)
D2054-1-13
Temporary Revision Number
5 - Apr 5/2004
©
Cessna Aircraft
Company
5 years NO
YES
NO
NO
NO
2-28A