Char-Broil 465133003 User Manual

Tabletop Propane Gas Grill
Model 465133003
For Outdoor Use Only
Please read Safety and Precaution statements, Grill
Maintenance, Leak Testing Your Grill, and Lighting your grill
before using grill for first time.
cleaners, paint
To the installer:
To the consumer:
Call Grill Service Center for Help and Parts
1-800-241-7548
1-800-387-6057
Open 24 hours – Seven days a week.
Safety Symbols
Leave instructions with consumer for future
reference.
Please keep these instructions for future
use.
• If you need help or warranty parts call , U.S.,
or , CAN., or send a FAX to 1-706-576-6355.
Business hours:
• To order non-warranty replacement parts or to buy
accessories ( ) call 1-800-993-2677 or send a
FAX to 1-706-565-2121.
• Please know your date of purchase prior to calling.
The symbols and boxes shown below explain what each
heading means. Read and follow all of the messages found
throughout the manual.
WARNING
CAUTION
CAUTION: Indicates a potentially hazardous situation which,
if not avoided, may result in minor or moderate injury.
WARNING: Be alert to the possibility of serious bodily injury
if the instructions are not followed. Be sure to read and
carefully follow all of the messages.
FAILURE TO FOLLOW THESE INSTRUCTIONS
COULD RESULT IN FIRE OR EXPLOSION WHICH
COULD CAUSE PROPERTY DAMAGE, PERSONAL
INJURY OR DEATH.
WARNING
FOR YOUR SAFETY
1. Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
2. An LP cylinder not connected for use shall not
be stored in the vicinity of this or any other
appliance.
FOR YOUR SAFETY
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open lid.
4. If odor continues, immediately call your gas
supplier or your fire department.
WARNING
• Grill is for outdoor use only. Grill should be operated in a
well-ventilated space. Never operate in an enclosed
space, garage or building. Your grill is not intended to be
installed in or on recreational vehicles and/or boats.
• Do not install or use grill
within 36” (10 ft.
recommended) of
combustible materials from
back and sides of grill. Grill
shall not be located under
overhead surfaces
that can catch fire.
• Never attempt to attach this grill to the self-contained LP
gas system of a camper trailer or motor home.
• It is the responsibility of the assembler/owner to
assemble, install and maintain gas grill. Do not let
children operate or play near your grill. Failure to follow
these instructions could result in serious personal injury
and/or property damage.
• Remove lid before lighting grill. When grill is not in use,
turn off control knob on regulator.
• Carefully follow instructions in this manual for proper
assembly and leak testing of your grill. Do not use grill
until leak checked. If leak is detected at any time, it must
be stopped and corrected before using grill further.
• Appliance area should be kept clear and free from
combustible materials, gasoline, bottled gas in any form
and other flammable vapors and liquids. Do not obstruct
flow of combustion and ventilation air.
• Ensure proper bottle position prior to lighting your grill.
Bottle should be vertical.
• Never try to light grill with lid closed! Buildup of gases is
very dangerous and could cause an explosion.
(closed
carport, garage, porch, patio)
CAUTION
Some parts may contain sharp edges – especially as
noted in manual! Wear protectives gloves if necessary.
Char-Broil Gas Tabletop / G102-001-0801 / 09-04-02

Char-Broil 465133003 Specifications

General

Brand	Char-Broil
Model	465133003
Category	Gas grill
Fuel Type	Propane
Number of Burners	4
Side Burner BTUs	10, 000
Ignition Type	Push-button
Material	Stainless steel
Grates Material	Porcelain-coated cast iron
Ignition System	Electronic
Weight	90 pounds

Summary

Safety Information

Symbol Definitions

Explains the meaning of CAUTION and WARNING symbols used in the manual.

General Safety Warnings

Covers storage of flammables, gas leak procedures, outdoor use, ventilation, and lighting precautions.

Sharp Edge Caution

Warns of sharp edges on parts and recommends protective gloves.

Customer Support and Parts

Contact Information for Help and Parts

Provides phone numbers and hours for warranty parts and general assistance.

Installation Safety Precautions

Compliance and General Checks

Adhere to codes, check burner flames, use correct cylinders, regulators, and supply systems.

Propane Gas Cylinder Handling

Details on cylinder type, upright storage, indoor disconnection, temperature limits, and outdoor storage.

Natural Hazards and Maintenance Warnings

Insects and Spiders in Venturi Tubes

Warns of clogs caused by insects, leading to poor flame or damage. Damage is not covered by warranty.

Warranty Information

One Year Limited Warranty Details

Outlines warranty coverage, exclusions, and contact information for claims.

Parts List

Assembly Instructions

Tools Needed and Pre-Assembly Checklist

Lists required tools and steps for checking parts before assembly.

Assembly Steps 1-2

Instructions for placing heat resistant shield, burner, and installing legs.

Assembly Steps 3-5

Instructions for attaching handles, heat plate, hinge brackets, and regulator.

Grill Operation and Leak Testing

Cylinder Connection and Leak Test Procedure

Guide on connecting the cylinder, performing a soap and water leak test, and troubleshooting leaks.

Lighting Instructions

Step-by-step guide for safely lighting the grill burner, including important warnings.

Pre-Cooking and Maintenance

Before Cooking for the First Time

Instructions for initial heat-cleaning of the grill to remove odors.

Turning Grill Off

Procedure for turning off the grill using the control knob and ensuring it pops up.

Storing Your Grill

Steps for proper storage, including cylinder removal and cap installation.

Grill Maintenance and Cleaning

Guidelines for cleaning the grill interior, grates, and removing meat drippings.

Troubleshooting Common Issues

Provides solutions for common problems like burners not lighting or flame burning out.