Page A-3
Repair and Service Manual
B
GENERAL INFORMATION & ROUTINE MAINTANENCE
Read all of Section B and this section before attempting any procedure. Pay particular attention to Notices, Cautions, Warnings and Dangers.
cause damage to seals, plastics, the electrical system,
body finish or seat material. Do not use pressure in
excess of 700 psi (4826 kPa) to wash vehicle.
Normal cleaning of vinyl seats and plastic or rubber trim
require the use of a mi
ld soap solution applied with a
sponge or soft brush and wipe with a damp cloth.
Removal of oil, tar, asphalt, shoe polish, etc. will require
the use of a commerc
ially available vinyl/rubber cleaner.
The painted surfaces of the vehicle provide attractive
appearance and durabl
e protection. Frequent washing
with lukewarm or cold water is the best method of
preserving those painted surfaces.
Do not use hot water, strong soap or harsh chemical
detergents.
Rubber par
ts should be cleaned with non-abrasive
household cleaner.
O
ccasional cleaning and waxing with non-abrasive
products designed for
‘clear coat’ automotive finishes
will enhance the appearance a
nd durability of the
painted surfaces.
Corrosive materials used as fertilizers or for dust control
can collect on the underbody
of the vehicle. These
materials will accelerate corrosion of underbody parts. It
is recommended that the underbody be flushed occa-
sionally with plain water. Thoroughly clean any areas
wher
e mud or other
debris can collect. Sediment packed
in closed areas should be loosened to ease its removal,
taking care not to chip or otherwise damage paint.
VEHICLE CARE PRODUCTS
To help maintain the vehicle, there are several products
available through local Distributors, authorized
Branches, or the Service Parts Department.
• Touch-up paint specially formulated to match
ve
hicle color
s for use on TPE (plastic) bodies
(P/N 28140-G** and 28432-G**).
• Multi-purpose Battery Protectant formulated to
form a long-
term, flexible, non-tacky, dry coating
that will not crack, peel or flake over a wide
temperature range (P/N 606312).
• Multi-
purpose Hand Cleaner is an industrial
strength cleaner c
ontaining no harsh solvents, yet
gently lifts grease off hands. May be used with or
without water (P/N 607636).
• Battery Maintenance Kit for complete battery
cleaning and watering
, with battery maintenance
instructions (P/N 25587-G01).
• Plexus plastic cleaner and polish removes minor
scratches fro
m windshield (P/N 606314).
SUN TOP AND WINDSHIELD
The sun top does not provide protection from
roll over or falling objects.
The windshield does not provide Complete
protection from tree limbs or flying objects.
The sun top and windshield are designed for weather
protection only.
Clean with lots of water and a clean cloth. Minor
scratches may
be removed using a commercial plastic
polish or Plexus plastic cleaner available from Service
Parts Department.
To Next Page
Loading...
