efacec EFAPOWER EV-QC45 - Maintenance Manual; Power Up Errors

28/32
8 MAINTENANCE MANUAL
ALL SERVICING MUST BE PERFORMED ONLY BY QUALIFIED PERSONNEL. DO NOT
ATTEMPT TO SERVICE THE EFAPOWER EV QC45 QUICK CHARGING STATION
YOURSELF.
BY OPENING THE DOOR OR REMOVING THE EFAPOWER EV QC45 QUICK
CHARGING STATION SIDE PANELS YOU RUN THE RISK OF EXPOSURE TO
DANGEROUS VOLTAGES!
IN CASE OF ANY KIND OF DOUBT REGARDING THIS CONTACT:
EFACEC WILL ASSUME NEITHER RESPONSIBILITY NOR LIABILITY DUE TO
INCORRECT OPERATION OR MANIPULATION OF THE EFAPOWER EV QC45 QUICK
CHARGING STATION.
EFACEC HAS TAKEN EVERY PRECAUTION TO PRODUCE AN ACCURATE, COMPLETE
AND EASY TO UNDERSTAND MANUAL AND WILL THEREFORE ASSUME NO
RESPONSIBILITY NOR LIABILITY FOR DIRECT, INDIRECT OR ACCIDENTAL PERSONAL
OR MATERIAL DAMAGE DUE TO ANY MISINTERPRETATION OR UNDESIRED
MISTAKES IN THIS MANUAL.
THIS MANUAL MAY NOT BE COPIED NOR REPRODUCED PRIOR TO WRITTEN
PERMISSION OF EFACEC.
BEFORE ANY MAINTENANCE, THE OPERATOR OR SERVICE TECHNICIAN MUST
NOT TOUCH THE CAPACITORS’ TERMINALS UNTIL THEY ARE DISCHARGED AND
REACH THE SAFETY VALUE OF 50V (D.C.).
8.1 POWER UP ERRORS
The following errors / messages can occur when the Quick Charging Station powers up.
Table 3 - EFAPOWER EV-QC45 Power Up Errors
Fault
Possible Cause
Action
The display does not
start
Circuit breakers Q3 and/or Q7 are OFF
Switch circuit breakers Q3 and/or Q7 ON
Unit A6 (auxiliary power supply)
failure
Check and replace unit A6 if necessary
Display failure
Check and replace unit if necessary
Earth Leakage Fault
Current higher than expected
Disconnect and reconnect power (by
turning the power to the charging station
off then back on again. If the message
continues to be displayed, call Efacec
Customer Support.
The charger does
not start charging
The card is not accepted
Use a valid and authorized card
Emergency Stop Button pressed
Turn the Emergency Stop Button to
allow the charge
Electronic Power Systems Unit
Rua Eng.º Frederico Ulrich - Apartado 3078
4471-907 MOREIRA MAIA - PORTUGAL
Tel: (+351) 229432248 - Fax: (+351) 229403209
apv-sa@efacec.com
www.efacec.com
Electronic Power Systems Unit
2725 Northwoods Parkway, Ste. B
Norcross, Georgia 30071 USA
Tel: (1) 470 395-3648 -
Fax: (1) 770 446 8920
support.eem.usa@efacec.com
www.efacecusa.com