Gardner Denver INTEGRA EFD99E - General Information

13-20-604 Page 8
LIST OF ILLUSTRATIONS
Figure 1-1 – Compressor Cycle....................................................................................................................9
Figure 1-2 – Compressor Illustration...........................................................................................................10
Figure 2-1 – Typical Compressor Room.....................................................................................................12
Figure 2-2 – Air Flow Chart.........................................................................................................................12
Figure 2-3 – Cold Weather Installation .......................................................................................................13
Figure 4-1 – Control Schematic ..................................................................................................................24
Figure 4-2 – Key Pad ..................................................................................................................................25
Figure 4-3 – Wiring Diagram – Full Voltage................................................................................................29
Figure 4-4 – Wiring Diagram – Wye Delta..................................................................................................31
Figure 4-5 – Wiring Diagram – Less Starter ...............................................................................................33
Figure 5-1 – Flow Diagram..........................................................................................................................35
Figure 5-2 – Approximate Oil System Capacities.......................................................................................37
Figure 5-3 – Oil Change Interval.................................................................................................................37
Figure 5-4 – Oil Level Gauge, Oil Fill and Oil Drain....................................................................................42
Figure 5-5 – Oil Filter ..................................................................................................................................43
Figure 6-1 – Air Filter ..................................................................................................................................47
Figure 7-1 – Belt Tension – 3VX Belts........................................................................................................51