•
The sequence is repeated progressively to
rd
th
shift 3 and 4 (top gear).
Recommended shifting speed
st nd
1 2
0-20 km/hr 15-30 km/hr
speed, close the throttle, press the clutch
nd
lever and shift to gear by depressing the
2
gearshift pedal.
rd
th
3 20-40 km/hr 4 30 km/hr and above
22
During first 1000 km, do not operate the
vehicle at more than 65 km/hr speed in
•
After the engine has been warmed up, the
vehicle is ready for riding.
top gear, 45 km/hr in third gear, 30 km/hr
in second gear and 15 km/hr in first gear.
Avoid full throttle operation.
RIDING
Running in
Flooded Engine
•
While the engine is idling, press the clutch
lever and depress the gearshift pedal to shift
st
into 1 (low) gear.
•
Slowly release the clutch lever and at the
same time, gradually increase engine speed
by opening the throttle. Coordination of the
throttle and clutch lever will assure a smooth
positive start.
•
When the vehicle attains a moderate
wear of engine components and increase its
service life.
If the engine fails to start after repeated
attempts, it may be flooded with excess fuel.
To clear a flooded engine, turn the ignition
switch “OFF” and turn the bystarter to “OFF”.
Close the throttle fully and crank the engine
several times with the kick starter. Turn the
ignition switch “ON” and start the engine
without using bystarter.
During initial running-in, newly machined
surfaces will be in contact with each other and
these surfaces will wear-in quickly. Running in
precautions till 1000 km will reduce initial
1
2
3
4
N
CAUTION
!!
Do not shift gears without operation of clutch
and without closing the throttle otherwise this
would lead to damage of gears.
BRAKING
•
For sudden deceleration/quick stopping,
close the throttle and apply the front and
rear brakes simultaneously.
•
For normal braking, close the throttle and
gradually apply both front and rear brakes
simultaneously while shifting down gears to
suit your road speed.
To Next Page
Loading...
