Honeywell HON P095NG Series User Manual

Decommissioning,storage,renewedstart‐up,disposal
UsermanualforHONR100gaspressureregulatorwithHONP095NGpilot  79
Observethefollowingrules:
 Alldeviceopeningsandfittingsmustbesealedandprotectedfromsoilinganddamage.
 Thedevice’smaintenanceconditionmustbeindicatedwithalabel:
 Datewhenmaintenancewaslastperformed
 Operatingtimesandoperationcyclessincethelasttimemaintenancewas
performed
 Donotstorethedeviceoutdoors.
 Storethedeviceinadryanddust‐freeenvironmentonaflatsurface.
 Donotexposethedevicetoanyaggressivemedia,ozoneorionizingradiationortodi‐
rectheatsources.
 Storageconditions: 
 Temperature:0 °Cto25 °C(32 °Fto77 °F)
 Relativehumidity:< 55%. 
 Avoidmechanicalvibrations.
 Storageperiods:Checkthedevicefordamageandsoilingatleastannually.Whenit
comestomaintenancecycles,taketheprecedingoperatingtimeintoaccountinaddi‐
tiontothestoragetime.


9.3 Puttingthegaspressureregulatorbackintooperation

Riskofinjuryposedbyburstingpartsintheeventthattheyaresubjectedtopressurein
thewrongdirection
Thedevicehasbeendesignedforaspecificdirectionofflow,whichislabeledonthedevice.
Subjectingthedevicetopressureinthewrongdirectionmayresultinseriousinjurycaused
byburstingparts.
 Pressurizethesystemonlyontheinletside.

Thisprocedurecanbeusedifthepilot’srequiredsetpointsareknown,theywerealreadyset
duringearliercommissioning,andredoingoradjustingthesettingsisoutofthequestion.

Afterbeinginadepressurizedstate,theadjustmentprocessforthegaspressureregulator
willberelativelysluggish.Duringcommissioning,alwaysmakesuretowaitbetweenthe
individualstepsuntilthedesiredstateisreached.


Thenumbershavethefollowingmeaning:
Storingdevicesthathave
alreadybeeninoperation
andthatareintendedto
beputbackintoopera‐
tionlateron
Pressurizedparts
Puttingthevalveback
intooperation
Basicpointers
Gasregulatinglinecom‐
ponents

Honeywell HON P095NG Series Specifications

General

Brand	Honeywell
Model	HON P095NG Series
Category	Controller
Language	English